Invacare Storm 4 Series, Service Manual

Page: 74 / 102

Invacare® Storm⁴ Series
Fig. 6-77 Lifter column completely retracted
6.10 Batteries
CAUTION!
Injury hazard and possible material damages if batteries are handled improperly
The installation of new batteries may only be carried out by authorised specialists.
– Observe the warning information on the batteries.
– Only use battery versions stated in the specifications.
CAUTION!
Fire and burns hazard if battery terminal is bypassed
– Take great care to ensure that the battery terminals are never short-circuited with tools or mechanical
mobility device parts.
– Ensure that the battery terminal caps have been replaced if you are not working on the battery terminals.
CAUTION!
Risk of crushing
Batteries can be extremely heavy. This results in injury hazards to your hands.
– Handle the batteries with care.
– Ensure that batteries do not fall to the ground when removed from chassis.
– Pay attention to hands.
– Use proper lifting techniques.
WARNING!
Burn hazard
Injury hazard due to discharged acid.
– Always wear acid-proof protective gloves when handling batteries.
– Always wear protective goggles when handling batteries.
What to do if acid is discharged
– Always take clothing which has been soiled by or dipped in acid off immediately!
– Rinse any areas of your skin which has come into contact with battery acid off immediately with plenty of
water!
If contact with eyes is made
– You should also consult an eye specialist immediately afterwards!
When removing, take care of small parts such as screws and washers. Put all small parts down so that they can
be installed in correct sequence.
6.10.1 General Instructions on Handling Batteries
• Never mix and match different battery manufactures or technologies, or use batteries that do not have similar
date codes.
• Never mix gel with AGM batteries.
• The batteries reach their end of life when the drive range is significantly smaller than usual. Contact your provider
or service technician for details.
• Always have your batteries installed by a properly trained mobility device technician or a person with adequate
knowledge. They have the necessary training and tools to do the job safely and correctly.
74 1533060-N