Daedong CK22, Workshop Manual

Page: 342 / 372

11-10 DS35-W00 May. 2007
CLUTCHCLUTCHCLUTCHCLUTCHCLUTCH
TRANSMISSIONTRANSMISSIONTRANSMISSIONTRANSMISSIONTRANSMISSION
ENGINEENGINEENGINEENGINEENGINE
HSTHSTHSTHSTHST
FRONT AXLEFRONT AXLEFRONT AXLEFRONT AXLEFRONT AXLE
STEERINGSTEERINGSTEERINGSTEERINGSTEERING
BARKEBARKEBARKEBARKEBARKE
ELECTRICELECTRICELECTRICELECTRICELECTRIC
INDEXINDEXINDEXINDEXINDEX
HYDRAULICHYDRAULICHYDRAULICHYDRAULICHYDRAULIC
GENERALGENERALGENERALGENERALGENERAL
REAR AXLEREAR AXLEREAR AXLEREAR AXLEREAR AXLE
CK22/CK22H
3R 3.0
0.85Y
12
71WR 0.5
P1
RL 0.85 66
196WA02B
2.3 CHARGING
When the ignition key is turn to the “ON” position with
the engine stopped, the charge warning lamp on the
instrument panel comes on.
This is done as the power from instrument panel flows
through the diode in the alternator to ground.
When the alternator starts to operate after the engine
is started, approx. 14 V of voltage may flow to the charge
warning lamp. However, this voltage is blocked by the
diode and the lamp goes out due to a loss of ground. If
the alternator is in a normal charge condition but the
charge warning lamp does not go off after the engine
is started, the diode may be faulty. The number (12) in
the circuit diagram is the line that supplies alternating
current to the tachometer on the instrument panel.
60A
ALTERNATOR
STARTER MOTOR
To Charging
Lamp
To Preheating
Lamp
To Hour meter
M
BATTERY
RLY:STARTER
BA
TTER
Y CABLE(-)
BA
TTER
Y CABLE(+)
DIODE
AM ACC
OFF
ACC
ON
GL
ST
ON GL ST
B+
+ - DIODE
GND
ENGINE STOP
SOLENOID
PULL
COIL
RELA
Y
ENGINE ST
OP
SOLENOID
25A 10A
UNITS/HOLD COIL
PREHEAT CONT
TIMER RELAY
SIGNAL LAMP GND
1Hz ON
ST
Holding
COMBIMETER
PREHEA
T PLUG
RELA
Y: PREHEA
T
SW
: CLUCH
Pull-in
0.77A 32A
P2
11
3
P1
12
3 R 5.0
2 R 5.0
IC REG
71WR 0.5
57 PB 0.5
12 R 3.0
3 R 3.0
62 LR 0.85
62 LR 0.85
42 BY
0.85
62 LR 0.5
43 BR 3.0
3 R 3.0
6 R
W
3.0
3 R 3.0 41 BR 0.85
66 RL 0.85
73 YL 0.5
41 BR 0.85
68 GY
0.5
0.85W 2.0 Or 0.5 BrR
0.85L
0.85W
0.85 B
2.0W
(+14.5V)
3 R 3.0
RERAY+
ON
GND SIG
105
66
001 001 001 001 001 001
001
104
103 7
66
7
66
001
196WA56A
ELECTRIC SYSTEM - OPERATION PRINCIPLE