Zoomlion ZCC1100, Operator'S Manual, Page: 103 / 291

履带起重机操作手册
安
全
准
则
Operator’s Manual for Crawler Crane
Operator’s Manual for Crawler Crane
Sa
fe
ty
G
u
id
e
lin
e
s
ZCC1100H Crawler Crane 3-21
d) While filling the fuel tank or the hydraulic tank: smoking and the use of fire or open flames
is strictly prohibited.
e) When filling the fuel tank through the filler pipe, electrostatic discharges may occur
between the equipment and the fuel dispensing system:
1) Always make sure that there is a good metallic contact between the pump nozzle and
the filler pipe.
2) Or before refueling, create a conductive connection between the equipment and the
fuel dispensing system.
f) If any fuel has spilled while refueling,
1) Wipe all excess or spilled fuel off the equipment immediately.
2) Neutralize any fuel on the ground with bonding agents.
g) After refueling, only start the diesel engine when:
1) The tank cab which can be locked has been properly replaced on the tank.
2) The equipment has left the area and the suction hose of the refueling system has
been removed.
3) Auxiliary staff is no longer in the vicinity of the equipment.
h) Do not use starting auxiliary device containing ether due to the risk of explosion.
i) Do not carry any combustible liquids on the equipment, except for the tanks provided for
this purpose.
j) Never use any combustible liquids to clean the equipment.
k) In the center power unit area:
-
Never store cleaning cloths, rags, etc.
-
Always remove flammable residues and deposits (for example: pools of oil, dry leaves,
pine needles, ash, waste paper, etc) regularly.
l) Irregularly check that protective covers, cable and hose holders are complete and fit
tightly.
m) The following are strictly prohibited near the battery acid electrolyte: smoking, fire and
open flame, ignition sources/electrical devices.
CAUTION
Hydraulic oil that is on fire can only be successfully extinguished with a fire
extinguisher at the very start of the fire. If not extinguished quickly, the fire will expand
into a full-fledged fire resulting in a total loss of the equipment.
WARNING
(1) When refueling the equipment, an explosive mixture of gases may be created.
(2) Escaping diesel fuel or hydraulic oil may ignite if it comes into contact with a hot
surface.
For reference only.
Operators manual should be consulted and adhered to.