![background image](http://html1.mh-extra.com/html/karcher/km-75-w-g/km-75-w-g_manual_3738470015.webp)
-
4
DANGER
Risk of injury, risk of damage!
Observe the weight of the appliance when
you load it!
Remove the cardboard.
Remove the wooden blocks that secure
the wheels and raise the device from
the palette by hand.
Release the parking brake on the steer-
ing roller.
The push handle is folded onto the cover
upon delivery. Fasten it before initial startup.
Loosen the screws.
Align the pushing handle.
Tighten the screws.
The side brush is included with delivery and
is not installed on the device.
Install the side brush before initial start-
up, see the chapter "Replacing the side
brush".
DANGER
Risk of injury! Switch off the appliance prior
to removing the waste container.
ATTENTION
Only operate while the appliance hood is
closed. The appliance is equipped with a
hood contact switch to protect the operator.
The motor starts up only when the appli-
ance hood is closed.
Park the sweeper on an even surface.
Switch off engine.
Lock parking brake.
Danger
Risk of explosion!
–
Only use the fuels specified in the Op-
erations Manual.
–
Do not refuel the machine in enclosed
spaces.
–
Smoking and naked flames are strictly
prohibited.
–
Ensure that no fuel reaches the hot
open surfaces.
Switch off the motor by setting the key
switch to position 0/OFF.
Open fuel filler cap.
Use "regular unleaded petrol".
Fill tank to max. 1 cm below the lower
edge of the filler nozzle.
Wipe off any spilt fuel and close fuel fill-
er cap.
NOTICE
The machine can be operated for a maxi-
mum of 2.0 hours on a full tank.
Carry out the daily maintenance tasks (see
section "Maintenance and Care").
DANGER
Ensure that there is adequate ventilation or
provision for diverting the exhaust gas
while operating the appliance in closed
rooms (risk of poisoning).
NOTICE
The device has an automatic choke.
When the motor starts, the roller brush and
side brushes rotate.
1 Fuel cock, open
Open the device hood.
Open the fuel supply.
Turn the rotating knob parallel to the
hose of the fuel tap.
Close cover.
Turn the main switch to "1".
Pull the starter rope slowly until a resist-
ance can be felt.
Pull starter rope swiftly.
When the motor starts running, let go of
the starter cord.
NOTICE
The drive speed for forward drive can be
adjusted steplessly depending on the posi-
tion of the lever.
Release parking brake.
Pull the lever for forward drive.
Release the lever for forward drive. De-
vice comes to a halt.
When moving the device backwards,
pull back on the push handle.
Driving over fixed obstacles which are 30
mm high or less:
Raise bulk waste flap.
Drive forwards slowly and carefully.
Driving over fixed obstacles which are
more than 30 mm high:
Only drive over these obstacles using a
suitable ramp.
Danger
Risk of injury! If the bulk waste flap is open,
stones or gravel may be flung forwards by
the roller brush. Make sure that this does
not endanger persons, animals or objects.
몇
Warning
Do not sweep up packing strips, wire or
similar objects as this may damage the
sweeping mechanism.
NOTICE
To achieve an optimum cleaning result, the
driving speed should be adjusted to take
specific situations into account.
An optimum cleaning result can only be
achieved if the bulk waste flap has been
lowered completely.
Empty the waste container at regular inter-
vals during the sweeping operation.
Clean the dust filter at regular intervals dur-
ing operation.
NOTICE
To sweep up larger items up to a height of
50 mm, e.g. cigarette packs, the bulk waste
flap must be raised briefly.
Raising bulk waste flap:
Pull the lever for raising the bulk waste
flap.
Lowering the bulk waste flap:
Release the lever for raising the bulk
waste flap.
Move the lever to lower the side brush
to the front. The side brush will be low-
ered.
Close wet/dry flap
Open wet/dry flap.
NOTICE
This protects the filter from moisture.
Pull the handle of the filter clean-off out
several times and reinsert it.
DANGER
Risk of injury! Switch off the appliance prior
to removing the waste container.
ATTENTION
Make sure the seal strip is not damaged
while emptying the waste container.
The max. load of the waste container is 40 kg.
Switch off engine.
Shake off dust filter.
Pull lock bow of the waste container up-
ward.
Pull out the waste container.
Empty waste container.
Push in the waste container.
Push lock bow of the waste container
downward.
Before Startup
Unloading tips
Net weight (transport weight)
84 kg
Unloading
Installing the pushing handle
Install side brush
Start up
General notes
Refuelling
Inspection and maintenance work
Start the engine
Operation
Drive the machine
Driving over obstacles
Sweep
Sweeping with bulk waste flap raised
Sweeping with side brushes
Sweeping dry floors
Sweeping damp or wet floors
Cleaning the dust filter
Emptying waste container
15
EN
Summary of Contents for KM 75 W G
