PS
P2.0
000
OE35
Version no
T-code
F-code
Section
C-code
Planned Maintenance Procedures
50
Service Manual
1997-10-21
3. Services to be performed annually
or every 1200 operating hours
The annual planned maintenance service will take a longer
period of time to complete than does the monthly service.
This would be a good time to arrange other repairs that have
been noted on the monthly service.
3.1. Inspection
All of the services and inspections listed in sections 1 and 2
for the daily and monthly inspection should be performed at
this time. The inspection procedure should be more thorough,
and minor deficiencies should be corrected.
3.2. Transmission
The transmission fluid should be drained once a year. The
drain port is located on the lower portion of the side cover
opposite the drive tire. Remove the plug to drain the
transmission fluid. Flush the transmission case with safety
solvent. Pour clean safety solvent into the fill port on top of
transmission case. With drive tire off the floor, allow solution
to run out of drain port while transmission is running. Stop
flushing when the solution runs clean. Allow the solvent to
drain well before replacing the drain plug. Replace the drain
plug. Refill the transmission with the proper clean oil before
operating truck.
3.3. Battery
At approximately 1500 hours, contact an authorized battery
dealer to determine the overall condition of the battery.
Determine if the battery needs to be washed down. This can
only be done by properly equipped and trained personnel.
Return
Summary of Contents for OE35
Page 2: ...Return ...
Page 10: ... BT Products 8 Table of Contents Return ...
Page 331: ...Return ...
