DANA SPICER PACCAR 220ev, Руководство по устранению неисправностей

Страница: 4 / 761

4
Safety Warnings
Modifications of the Vehicle
Modifying the vehicle could make it unsafe. Some
modifications could affect the vehicle's electrical
system, stability, or other important functions. For
no reason should the electric powertrain be
modified. Modification to any of Dana’s components
will void the warranty. Modifications to the electric
chassis could cause death or personal injury.
Warning: Connecting to an unapproved
CAN (Controller Area Network) bus may
trigger CAN fault codes. The manufacturer
will not warrant failures or damage caused
to the CAN bus components or vehicle
when the failure or damage due to improper
connections to the CAN bus or improper
messages.
Cooling System Filler Cap
Warning: Do not remove the radiator fill
cap while the powertrain is hot. Scalding
steam and fluid under pressure may
escape. You could be badly burned. Failure
to comply may result in death or personal
injury.
Coolant
Caution: To prevent corrosion problems in
cooling systems, the following
recommended best practices should be
observed:
•
The coolant should consist of 60%
ethylene glycol, 40% de-ionized water
(not distilled water).
•
A minimum of 50% ethylene glycol is
required.
• The ethylene glycol must contain some
type of active corrosion inhibitor.
•
Do not mix different types of coolant.
Fire Extinguisher
Ensure that an approved fire extinguisher is within
the driver's reach and easily accessible for first
responders. Routinely check the fire extinguisher
according to its manufacturer’s instructions. If the
fire extinguisher has been used, it must be replaced
with a new fire extinguisher or refilled according to
the manufacturer’s instructions before the truck can
be returned to service.
Fire Instructions:
During a fire, certain plastic seals can produce
gases which with water form a corrosive acid. Do
not touch any fluid on the vehicle.
1. Contact firefighters.
Note:
Do not attempt to put out a battery
pack fire with the provided fire extinguisher.
2. Create a safety perimeter of at least 6 feet
around the vehicle.
3. If it is possible, take the keys out of the ignition
and turn the 12V Disconnect to the “OFF” position.
Oils and Lubricants
Various kinds of oil and other lubricants used on the
vehicle may constitute a health hazard if they
contact the skin. This also applies to electric
powertrain coolant, refrigerant in air conditioning
systems, and battery acid. Do not contact vehicle
liquids without the appropriate personal protective
equipment.
Caution:
The refrigerant lube used on this
truck is different from the typical refrigerant
lube used for PACCAR vehicles. Failure to
use the correct refrigerant lube could result
in isolation failures.
Maintenance Activities
When carrying out maintenance work under the
cab, make sure the cab is fully tilted and locked to
prevent it from falling back accidentally.
Following a collision, only tilt the cab in an
emergency. The tilting mechanism may be
damaged, and a high voltage hazard might exist.
(The end stop may no longer be on the lifting
cylinder.)
Warning:
Always support the vehicle with
appropriate safety stands if it is necessary
to work underneath the vehicle. A jack is
not adequate for this purpose.