FD2200 stage 5
/ Translation of the original instructions
LUBRICATION POINTS WITH GREASE
Find the lubrication points following the scheme below. Grease the rear axle pivots, the pedals, the PTO
transmission belt guide pulley, the pivot connected to 2 points joint of the cutting deck, the grass catcher lifter
arms, the turbine shaft and its bearing every 50 hours (fig. no. 24).
TROUBLE-SHOOTING GUIDE
PROBLEM
CAUSE
REMEDY
With the key in the «AVV.»
[ON] position the instrument
panel remains off
The battery is not providing any
current
- Check the connecting cables
- Check the electrolyte level
- Recharge the battery
- Replace the main fuse
The instrument panel comes
on, but with the key in the
«ON» pos., the starter motor
does not turn
The battery is not providing
enough current
- Recharge the battery
No consent is given to start
- Feed pedals in the «STOP» position
- Disengage the blades
- Sit on the driving seat
- Disengage the PTO
The starter motor turns but the
engine will not start
No diesel flow
- Check fuel level in the tank
- Check the diesel filter (and replace if
necessary)
- Check that the breather hole in the fuel
cap is not blocked
Plugs not warmed up enough
with cold engine
- Wait for the plug light to go out
The timer does not give the
consent
- Check the connections
- Replace the timer
The electro-stop does not run
its full travel
- Check the travel of the electro-stop
- Replace the electro-stop
Loss in engine performance
while cutting
Forward speed too high for the
grass height
- Reduce speed
- Lift the cutting deck by a few notches
Engine stops when blades are
engaged
No consent is given for blade
engagement
- Check the blades push button
- Operator sitting on driving seat
- Close the grass catcher
- Check the PTO engagement
electrovalve
16
Summary of Contents for FD 2200 STAGE 5
