IQ PLUS CHARGER (EXTERNAL)
General Information
Page 8-2
2008-2011 Domestic Battery Charger Maintenance and Service Manual
8
IQ PLUS EXTERNAL CHARGER FEATURES
• Charge Interlock
IQ Plus battery charger DC plugs have three pins rather than two blades common on most standard
charger plugs. Two of these pins are the positive and negative leads as on standard chargers; the third
pin is a sensing lead that is the communication link between the charger and the onboard computer.
When the charger plug is plugged into the vehicle receptacle, the onboard computer locks out the vehi-
cle drive system. This prevents the possibility of driving the vehicle while the charger is plugged in and
potentially damaging the vehicle and charger.
• Long-Term Storage Charge
IQ Plus vehicles with IQ Plus chargers are designed to be left connected with AC power to the charger,
during off-season or long-term storage. The onboard computer will automatically activate the charger
every 15 days. To return the vehicle to service, unplug the charger DC cord, wait 15 seconds for the
computer to reset, and plug the charger back in.
See following WARNING.
This will ensure the batter-
ies are at their optimum charge prior to returning the vehicle to service.
ý
WARNING
• The charger plug must be pulled slowly from the receptacle. Jerking or pulling the DC cord
out quickly could cause arcing and burning that could damage the plug and receptacle and
could cause batteries to explode.
BATTERY WARNING LIGHT
IQ Plus vehicles feature a dash mounted battery warning light (above the steering column) that, when the
vehicle is in operation, indicates low battery voltage or, when the vehicle is being charged, indicates a charg-
ing problem. The battery warning light is controlled by the onboard computer.
When the batteries receive an incomplete charge because 1) the DC power cord is disconnected, 2) AC
power to charger is interrupted, 3) automatic charger shut-off occurs after 16 hours of operation, or 4) charger
malfunctions, the warning light will indicate as follows:
•
The battery warning light will not illuminate if the charge is 90% or more complete. The onboard com-
puter will retain in memory the amount of charge needed to replenish the batteries and will complete
the charge during the next charge cycle.
•
When the charger DC cord is unplugged during a charge cycle, the battery warning light will illuminate
and remain illuminated for 10 seconds if the charge is less than 90% complete but the vehicle has
enough power for 60 minutes of operation. This will alert the operator that the vehicle may be used, but
that it must be charged to completion as soon as possible.
•
The battery warning light will repeatedly illuminate for 10 seconds, at 4 second intervals, if the charger
times out at 16 hours and the batteries are not sufficiently charged. This indicates an abnormal charge
cycle. The charger and batteries should be checked by your Club Car distributor/dealer.
•
The battery warning light will repeatedly illuminate for 10 seconds, at 4 second intervals , during a
charge cycle (with the DC plug still connected) if AC power to the charger is interrupted. The light will
go out when AC power is restored.
UL AND CSA LISTING
When operated on a 120-volt / 60 Hz electrical system, the following IQ Plus battery chargers have been
listed by Underwriters Laboratories and by the Canadian Underwriters (thereby meeting the criteria of the
Canadian Standards Association).
IQ Plus external battery charger model: 25730-11.
Summary of Contents for 2008-2011
