![background image](http://html1.mh-extra.com/html/club-car/2008-2011/2008-2011_maintenance-and-service-manual_2626718051.webp)
POWERDRIVE CHARGER (EXTERNAL)
Test Procedures
2008-2011 Domestic Battery Charger Maintenance and Service Manual
Page 3-23
3
6. If the AC line fuse does not blow or the AC circuit breaker does not trip, check the transformer secondary
coil voltage.
7. Disconnect AC cord from the wall outlet.
8. Using alligator clips and a multimeter set to 500 volts AC, connect the multimeter probes to the second-
ary transformer coil wires (1 and 5).
9. Connect the AC cord to the wall outlet and monitor the multimeter for the secondary coil voltage. If mea-
sured voltage is approximately 85 volts AC or lower for the secondary coil, the transformer is shorted
internally and must be replaced
(Figure 3-22, Page 3-23)
.
10. If the voltage reading is normal (86 volts AC or higher), the transformer is operational. Disconnect the AC
plug from the wall receptacle and check the continuity of the DC circuit.
See Test Procedure 5 –
Charger DC Circuit Continuity Test on page 3-21.
11. When troubleshooting and repairs are complete, properly connect relay wiring.
See following WARN-
ING.
ý
WARNING
• The relay wiring must be properly connected prior to placing the charger back into normal
service. Failure to properly connect the relay wiring could result in property damage, severe
personal injury, or death.
TEST PROCEDURE 7 – BATTERY STATE OF CHARGE TEST
See General Warning, Section 1, Page 1-1. See additional WARNING on page 3-1.
1. With the batteries fully charged, disconnect the DC charger plug for approximately 20 seconds and then
reconnect it. The ammeter should jump to a reading between 14 and 18 amps and then taper to below
5 amps within 15 minutes.
2. If the charger does not taper to below 5 amps within 15 minutes, batteries may not be receiving a full
charge and the onboard computer should be checked.
See Test Procedure 2 – Onboard Computer on
page 3-19. See following NOTE.
Figure 3-22 Transformer Test Wiring Diagram
TA
N
5
7
6
4
3
1
2
DC CORD
RED
RED
BLUE
BLACK
BLACK
BLA
CK
BLACK
BLACK
AC CIRCUIT
BREAKER
AC INPUT PLUG
AC CORD
GREEN
CASE
GROUND
WHITE
TAN
TAN
TA
N
TA
N
DIODES WITH
HEATSINK
FUSE
AMMETER
TRANSFORMER
RELAY
PRIMARY
COIL
SECONDARY
COIL
Summary of Contents for 2008-2011
