MQ Power DIS185SSI4F, Руководство по эксплуатации

Страница: 19 / 74

DIS185SSI4F AIR COMPRESSOR • OPERATION MANUAL — REV. #0 (12/19/16) — PAGE 19
1. Radiator/Cap — Holds coolant/water necessary to
allow the engine to operate at a safe temperature. Allow
the engine to cool before removing radiator cap. The
possibility exists of severe scalding if cap is removed
while engine is hot.
2. V-Belt — ALWAYS make sure the V-belt is properly
tensioned. A loose or defective V-belt can adversely
affect the performance of the engine.
3.
Alternator
— Provides alternating current to the
+12VDC electrical system. Replace with only
manufacturer recommended type alternator.
4. Starter Solenoid — Starts engine when ignition key
is placed in the "
ON
" position.
5.
Secondary Hydraulic Filter
— Spin-on type, filters
hydraulic oil for contaminants not filtered by the primary
hydraulic filter.
6. Primary Hydraulic Filter — Spin-on type, initial
filtration of hydraulic oil for contaminants.
7.
Compressed Air Receiver Tank
— Stores 185 cubic
feet of compressed air.
8.
Compressor Oil Sight Tube
— Indicates the amount
of oil in the air receiver tank oil chamber. Fill with
synthetic type oil/lubricant as specified in Table 1.
9. Oil Chamber Fill Cap — Remove this cap/plug and fill
with type oil as specified in Table 1.
DO NOT
remove
cap until unit has cooled and the high internal pressure
within the air receiver tank has dissipated.
10. Oil Chamber Drain Plug — Remove this plug to drain
the oil in the oil chamber.
11.
Tie-Down Points
— Used to tie down air compressor
with straps or chains to allow even application of force
to the front and rear of the equipment during transport.
12. Chock Block — Place blocks (not included as part of
the air compressor package) under each trailer wheel
to prevent rolling.
13.
Engine Oil Drain Plug
— Remove this plug to drain
the oil from the engine crankcase.
14.
Battery
— Pr12VDC to the electrical system.
Replace with only recommended type battery.
15. Documentation Canister — Storage for documentation
and other information regarding the air compressor.
16.
Side Marker Lamps —
There are four side marker
lights located on air compressor. The front circular
lights (tongue side) are amber. The rear rectangular
reflectors are red.
MAJOR COMPONENTS (BATTERY SIDE)
H
15
14
2
1
3 4 5
8
11
11
10
9
6
7
13
12
16
Figure 5. Major Components (Battery Side)