FUEL INJECTION SYSTEM
8-112
Fault code No. P1600 (FJR13ESG)
TIP
If fault code numbers “U0125” and “P1600” are both indicated, take the actions specified for fault code
number “U0125” first.
5
Malfunction in ECU.
Replace the ECU.
Refer to “REPLACING THE
ECU (engine control unit)” on
page 8-250.
Service is finished.
6
Delete the fault code and check
that the engine trouble warning
light goes off.
Confirm that the fault code has
a condition of “Recovered” us-
ing the Yamaha diagnostic tool,
and then delete the fault code.
Fault code No.
P1400
Item
Air induction system solenoid: open or short circuit is detected.
Fault code No.
P1600
Item
Signals cannot be transmitted between the ECU and the IMU.
Fail-safe system
Unable to start engine
Unable to drive vehicle
Diagnostic code No.
17
Tool display
0–5°: Upright
Less than approximately 30°: On the sidestand
Procedure
Hold the vehicle upright and place the vehicle on the sidestand.
Item
Probable cause of malfunc-
tion and check
Maintenance job
Confirmation of service com-
pletion
1
Connection of IMU coupler.
Check the locking condition of
the coupler.
Disconnect the coupler and
check the pins (bent or broken
terminals and locking condition
of the pins).
Improperly connected
→
Con-
nect the coupler securely or re-
place the wire harness.
Turn the main switch to “ON”,
then to “OFF”, and then back to
“ON”.
Check the condition of the fault
code using the malfunction
mode of the Yamaha diagnostic
tool. Condition is “Recovered”
→
Go to item 7 and finish the
service.
Condition is “Detected”
→
Go to
item 2.
2
Connection of ECU coupler.
Check the locking condition of
the coupler.
Disconnect the coupler and
check the pins (bent or broken
terminals and locking condition
of the pins).
Improperly connected
→
Con-
nect the coupler securely or re-
place the wire harness.
Turn the main switch to “ON”,
then to “OFF”, and then back to
“ON”.
Check the condition of the fault
code using the malfunction
mode of the Yamaha diagnostic
tool.
Condition is “Recovered”
→
Go
to item 7 and finish the service.
Condition is “Detected”
→
Go to
item 3.
Summary of Contents for FJR13AG
