5-4
4100 Bar Code Label Printer User's Manual
Helvitica condensed 9 pt italic
Co d e 39 18 p t
Printer Operation Problems
If your printer is not operating correctly, try locating the problem in the table
below:
Symptom
Cause
Solution
No power or loss
of power
AC power cable is
damaged or disconnected.
Make sure the power cable is
plugged into both the printer
and an outlet or power strip.
Replace the cable if it is
damaged.
Printer main power fuse is
burnt out in 115 VAC
printers, or circuit breaker
tripped in 230 VAC units.
Replace the fuse as shown in
Chapter 4. Reset the circuit
breaker for 230 VAC printers.
Labels stop
indexing
Media is sticking to the
paper path.
Clean any extraneous material
from the paper path and clean it
thoroughly. See Chapter 4.
Label gap sensor is not set
correctly.
Adjust the label gap sensor. See
Chapter 3.
Printer is out of media.
Load new media. See Chapter 3.
Label stock is loaded
incorrectly.
Check the media path. See
Chapter 3.
Printer is set for
continuous label stock.
Check the variable used with the
label stock type configuration
command <SI>T. See Chapter 7.
Printer slows down
Image bands or print
speed are incorrectly set.
Change the image bands or print
speed settings. See Chapter 7.
Image overrun condition
has occured and print
speed and image bands
were reset.
Change the image bands or print
speed settings. See Chapter 7.
Media jam occurs
Media is backed up behind
the cutter.
Push [FEED] button to perform a
cut.
Or, open the cover to remove
media from behind the cutter.
Reinsert the media through the
cutter's paper guide. Make sure
the slot on the cutter is clear.
Or, follow the procedures in
Chapter 4 for removing the
cutter blade and then cleaning it.
Summary of Contents for EasyCoder 4100
