Expresso Tie Stall
50 © 2012 Agricultural Instruments Corporation
(AIC) 608.526.6882
72560 Detacher
•
AIC provides this unit to accommodate different styles of pulsators (Diaphragm
and Direct acting. Therefore it is necessary to follow the service instructions
required for the style of pulsator in use. If other brands of pulsator is being
used flow the manufacturer
’
s service recommendations.
•
Pulsator Service is normally required every year or every 2000 hours of
operation (whichever comes first)
•
Check for any wear on the retractor rope replace if needed. Be sure the spool
is tight to the shaft.
Milk Line Shutoff
•
Replace Milk Line Shut
-
off Diaphragm a minimum of once per year or every
2000 operating hours whichever comes first.
•
To avoid undue stresses on the cover, even torque must be applied to the
fastener screws (do not over tighten!!) Over tightening will cause stresses on
the valve corners and create uneven pressure on the diaphragm reducing the
ability to seal properly
As Needed
Clean the non
-
milk contact (outside) surface of detachers, hoses and plastic housing
using a sponge and mild detergent, followed by a clear water rinse.
Service Instructions
•
Review the instructions to determine the
“
Responsibilities
”
and perform only
those steps in this section that you are responsible for performing.
•
Review the personal safety messages and installation specifications in Section
1 and instructions throughout this packet before starting the procedure(s) in
this section.
Yearly Maintenance
