Hog Technologies Stripe Hog SH5000, Руководство по эксплуатации

Страница: 45 / 122

45 45
Stripe Hog Systems
Damaged vacuum hose can be repaired by cutting
out the damaged area and splicing in new hose.
Temporary repairs can be made using duct tape.
Vacuum/Debris tank
The vacuum/debris tank is constructed from stain-
less steel panels that provide corrosion resistance
and low maintenance. There is a stainless steel
cutoff ball valve that automatically shuts off the
vacuum flow if the tank becomes full, protect -
ing the blower system. This valve reduces the
possibility of excessive water from damaging the
blower. If the cutoff ball valve shuts off the vac -
uum flow, the vacuum relief valve on the vacuum
filter canister will automatically open and reduce
the vacuum to near 0 to prevent damage to the
vacuum system.
A special filter bag (debris bag) is mounted on
retaining pins near the top the stainless steel liner
in the debris tank. The vacuum system creates
vacuum in the tank and debris mixed with water
from the Hog Head and vacuum intake hose flows
directly into the debris bag where solid debris
and particles over 100 microns are trapped. The
filtered water exits the filter bag and flows into
the debris tank where it accumulates until it is
drained by the drain valve at the bottom of the
tank or pumped out by the dirty water pump out
system. The filter system allows for quick drain -
ing and easy disposal of filtered waste water
while retaining the solids, enabling the operator
to regain tank capacity.
A site tube on the side of the debris tank indi-
cates the recovered water level and an opening
inspection port on top of the debris tank is used
to monitor the solid waste level. A 4” ball valve
allows for quick draining of the tank. Some water
can travel to the vacuum filter canister, therefore,
it should be drained each time the operator stops
the machine or at least once every 2 hours of
operation.
The filtered waste water is usually clean enough to
dump in swales alongside the road, vacant fields
and designated areas at airports. It should never
be dumped directly into lakes and ponds or any
standing water. Always check with the authorities
to ensure you are dumping within local guidelines.
The filter bag is biodegradable and designed to
slide out of the tank with the debris during dump-
ing. When installing a new bag, make sure to
Wear Points in Vacuum Hose
Cutoff Ball Valve
attach the loops at the top of the filter bag on
the rear, horizontal side of the hooks in the tank.
Do not wrap the loops around vertical section of
the hooks. The hooks and loops hold the bag in
position during operation and are designed to re-
lease the bag and allow it to automatically slide
out with the debris during dumping. The bag will
not stay in the proper position during operation
and may not release properly during dumping if
it is not installed properly.