Club Car Carryall 1500 2016, Руководство по техническому обслуживанию и ремонту

Страница: 98 / 436

7
Front Suspension STEERING AND FRONT SUSPENSION
2. Mark each front tire at the center of the tread face that is facing the rear of the vehicle. The marks should be at
the same height as the center of each hub. Measure the distance between the marks.
3. Roll the vehicle forward one-half wheel revolution until the marks appear on the forward facing surfaces of the
tires at the same height as the center of each hub. Measure the distance between the marks
(Figure 7-29, Page
7-16) . See following NOTE.
NOTE: The front measurement must be less than the rear measurement.
1186
Figure 7-29 Measure Toe-in
1187
Figure 7-30 Adjust Toe-in
4. Subtract the front face tire measurement from the rear face tire measurement. Proper toe-in is 3/16 to 1/4 inch
(4.8 to 6.35 mm) ±3/16 inch (4.8 mm).
Toe-in Adjustment – for vehicles equipped with steering damper accessory
1. Loosen the jam nuts on both ends of each drag link (Figure 7-30, Page 7-16) .
2. Rotate both of the drag links equally. To increase the toe-in, rotate both drag links counterclockwise. To decrease
the toe-in, rotate both drag links clockwise. Maintain an equal distance from the ball joint to the end of the
threads on each drag link
(Figure 7-31, Page 7-16) .
3. Tighten the jam nuts to 21 ft-lb (28 N·m).
4. Check the toe-in, and repeat the adjustment procedure if necessary.
5. After the toe-in adjustment is complete, the steering wheel should be at the center of its travel. If not, remove and
correct the position so it is as close to center as possible.
See Steering Wheel Installation on page 7-2.
2064
Figure 7-31 Adjust Both Drag Links To An Equal Distance
Camber Measurement
1. On a level, hard, and smooth surface roll the vehicle forward, then stop. Make sure the front wheels are pointed
straight ahead.
See following NOTE.
NOTE: Do not turn the steering wheel again during this procedure.
2. Use a large carpenter’s square and position it a few inches (cm) away from the center of one wheel (Figure
7-32, Page 7-17) .
Page 7-16 2016 Carryall 1500/1700 and XRT 1550 Maintenance and Service Manual