Club Car Carryall 1500 2016, Руководство по техническому обслуживанию и ремонту

Страница: 389 / 436

HYDRAULIC ATTACHMENT SYSTEM Electrical
19
AUXILIARY HYDRAULIC SWITCH
See General Warnings, Section 1, Page 1-2.
A
3
2
5
1
B
4
6
C
A. Extend Position B. Retract Position C. Alignment Notches
Terminals:
1. #18 Gray w1 2. #18 Red/White w82 3. #18 Gray w57
4. #18 Green w22 5. #18 Orange w12 6. #18 Yellow w23
2241
Figure 19-25 Auxiliary Hydraulic Switch Test (Rear View)
Testing the Auxiliary Switch
NOTE: The control circuit is protected by a 20-amp fuse. Check the fuse before this procedure is performed. See
Test Procedure 2 – Fuse on page 12-13.
1. Remove the auxiliary hydraulic switch. See Auxiliary Switch Removal on page 19-15.
2. Check the following locations for no continuity with switch in the “rest” position and continuity with switch in either
the “extend” or “retract” position
(Figure 19-25, Page 19-15) :
– Between terminal 5 (orange wire w12) and terminals 4 and 6 (light green wires w22 and 23)
– Between terminal 2 (red/white wire w82) and terminal 1 (gray wire w01)
– Between terminal 2 (red/white wire w82) and terminal 3 (gray/white wire w57)
3. If switch does not work as stated in previous step, replace switch. See Auxiliary Switch Removal on page 19-15.
4. If switch does work as stated in step 2 and the auxiliary hydraulic feature still does not work, check the following
items:
– Fuse.
– Joystick ON/OFF switch.
– Joystick switches.
– Auxiliary control valves. See Control Valves on page 19-20.
– Continuity of the wires involved.
Auxiliary Switch Removal
1. Set the joystick ON/OFF switch to OFF and remove both seats.
2. Disconnect battery. See Side-Post Battery: Disconnecting the Battery – Gasoline/Diesel Vehicles on page
1-3.
See Top-Post Battery: Disconnecting the Battery- Gasoline/Diesel Vehicles on page 1-4.
3. Cut the wire tie securing joystick harness to chassis (Figure 19-22, Page 19-11) .
4. Remove four screws securing control box cover/joystick assembly and pull assembly out enough to access
the switch.
See Joystick Removal on page 19-11.
2016 Carryall 1500/1700 and XRT 1550 Maintenance and Service Manual Page 19-15