Section 02
MAINTENANCE
Sub-Section 04
(STORAGE)
02-04-1
STORAGE
4
Engine Draining
Check engine drain hose running from engine
manifold fitting to outlet socket. Make sure there
is no sand or other particles in it and that it is not
obstructed so that water can leave the engine.
Clean hose and outlet socket as necessary.
CAUTION : Water in engine drain hose
must be free to flow out, otherwise water
could be trapped in engine. Should water
freeze in engine, severe damage will occur.
Check engine drain hose for obstructions.
Sportster and Speedster
TYPICAL
1. Drain tube
Challenger
TYPICAL
1. Drain tube
Fuel System
Sea-Doo Fuel Stabilizer (P / N 413 408 600) can be
added in fuel tank to prevent fuel deterioration
and carburetor gumming. Follow manufacturer’s
instructions for proper use.
CAUTION : Fuel stabilizer should be add-
ed prior engine lubrication to ensure car-
buretor protection against varnish deposit.
WARNING : Fuel is flammable and explo-
sive under certain conditions. Always
work in a well ventilated area. Do not smoke or
allow open flames or sparks in the vicinity. Al-
ways wipe off any fuel spillage from the boat.
Cooling System Flushing and Engine
Internal Lubrication
Cooling system has to be flushed with fresh wa-
ter to prevent salt, sand or dirt accumulation
which will clog water passages. This will be
achieved with a garden hose.
Refer to flushing, section 02-02 and follow the
procedure.
Internal Lubrication
Engine must be lubricated to prevent corrosion on
internal parts. This will be achieved by spraying
BOMBARDIER LUBE lubricant (P / N 293 600 006)
through air intake silencer.
1. After the flushing procedure and the engine has
been running as prescribed, spray BOMBAR-
DIER LUBE lubricant through air intake silencer
cover keeping engine at fast idle.
-
F04E0HC
1
F04E0IC
1
-
;
Summary of Contents for Challenger 5896
