SEPARATE DRIVE
AIR COMPRESSOR AND VACUUM PUMPS
SGH ‘B’ MODELS RATED 1/4-1 HP
INSTALLATION, OPERATION, PARTS LIST
AND MAINTENANCE
C85281
03/10
GENERAL
Operation and maintenance instructions as well
as parts information presented herein relate to the
following models:
SGH-3051B SGH-410B SGH-3V1B
SGH-405B SGH-510B SGH-4VB
SGH-505B SGH-610B SGH-5VB
SGH-605B SGH-610B SGH6VB
SGH-705B
SGH-705B
SGH-617B SGH-E1010B
AMBIENT CONDITIONS
Compressors and vacuum pumps should be
located in a well ventilated area where the air
is relatively cool, clean, and dry. A 95°F (35°C)
maximum
temperature
is
recommend
for
surrounding and inlet air, while 35°F (2°C) is the
minimum temperature recommended. NOTE:
UNIT REQUIRES NO LUBRICATION. BEARINGS
ARE FACTORY SEALED FOR LIFE.
FILTERS
NEVER OPERATE A COMPRESSOR WITHOUT
FILTERS. Intake filters must be kept clean for best
performance. To clean filter, lift off top from filter
housing, remove filter insert and blow dirt particles
from filter using compressed air. DO NOT CLEAN
FILTER WITH PETROLEUM BASED PRODUCTS.
Replace felt insert after several cleanings.
OSHA SPECIFICATION REQUIRE ALL BREATHING
AIR SYSTEMS TO MEET THE STANDARDS AS
SPECIFIED FOR “TYPE 1, GROUP D AIR,” AS
FURTHER DEFINED IN CGA PAMPHLET G-7.
THEREFORE, ALL COMPRESSED AIR BREATHING
SYSTEMS MUST INCLUDE AIR FILTRATION
EQUIPMENT FROM COMPRESSOR INTAKE TO
FINAL RESPIRATOR DEVICE.
WARNING
Establish a periodic time for checking and clean-
ing all filters to obtain maximum satisfactory
service. Filters should be checked for cleaning at
least every thirty days as required.
Always use an inlet filter on vacuum pumps to
prevent foreign material from entering the pump.
Thomas, part number - S62240, inline filter is
recommended for this purpose.
WARNING-These Products are suitable for
pumping atmospheric air. As defined in Com
-
pressed Gas Association Pamphlet G-7, Page
3, atmospheric air is mixture of elements and
compounds where nitrogen and oxygen com-
prise more than 99% with all other trace gases
comprising less than 1%. DO NOT USE THIS
PRODUCT IN CONTAMINATED ENVIRON-
MENTS OR FOR PUMPING MIXTURES OTHER
THAN ATMOSPHERIC AIR.
Page 1
Содержание CTS 330
