66
Cleaning
NOTE:
A stainless steel, micro-mesh
Filter Screen (P/N 41041)
is
available as a direct substitute for paper filter media. It is
cleanable and reuseable; designed to reduce cost of
operation and eliminate the refuse associated with use of
filter paper. Using it along with a good filter aid, such as
Giles Filter Powder (P/N 72004)
, gives the same result as
filter paper.
Model: GGF-400, GGF-720
6.2.
Cleaning the Filter Pan & Replacing Filter Media
1. Shutdown fryer using
Normal Shut-Down
, see
Section 5.5
2. Remove
filter pan
①
from fryer and lift off
pan cover
②
.
Clean and dry cover thoroughly.
3. If equipped, remove the
Crumb Screen
③*
, clean and dry
thoroughly.
4. Using the provided metal
Crumb Scoop
, remove
accumulated filter residue from the surface of the media
⑤
, especially around the edge of the
hold-down frame
④
.
5. Turn locking
levers
⑥
to disengage the
hold-down frame
from pan bottom. Remove frame, clean and dry
thoroughly.
6. Grasp edge of
soiled sheet of filter paper
⑤
, carefully
roll it up, taking care not to allow filter debris to fall
through
perforated screen
⑧
in the pan bottom, and
discard.
7. Clean
filter pan
, rinse thoroughly and dry completely. Be
certain to drain all water from the filter pan hoses.
8. Reassemble
filter pan
,
using one (1) fresh sheet of filter
paper (proper size 15-1/2” x 21-3/8”)
. Close all locking
levers, be sure they securely engage
hold-down frame
.
9. Replace
pan cover
and place assembled
filter pan
under
fryer. Reconnect hose at quick-disconnect coupling.
* Accessory, not included, purchased separately
1
2
3*
5
4
6
8
7
This section describes the procedure for cleaning the
filter pan
and replacing
filter media
. Perform this after each
Boil-Out Procedure (Section 6.1),
as well as part of a
daily cleaning routine
.
GILES recommends using a non-toxic, non-detergent, biodegradable degreaser cleaner, such as SIMPLE GREEN®
Crystal Foaming Spray Cleaner/Degreaser along with hot water, to clean the filter pan and components.
Wear thermal hand protection as safeguard from hot parts.
Discard
used
&
replace
with
new.
Содержание GGF Series
