Club Car Precedent 2014, Руководство по техническому обслуживанию и ремонту

Страница: 361 / 548

FUEL SYSTEM Fuel Tank
22
4. Connect battery. See Connecting the Battery – Gasoline Vehicles, Section 1, Page 1-4.
5. Turn the fuel shut-off valve to the open position (Figure 22-13, Page 22-21) .
6. Place the Forward/Reverse handle in the NEUTRAL position, chock the wheels, and the neutral lockout cam in
the MAINTENANCE position.
See following DANGER.
DANGER
• Repair all fuel leaks before operating the vehicle.
7. Start the engine and check for fuel leaks. If the fuel pump leaks, it must be replaced.
8. If no leaks are found, place the neutral lockout cam in the OPERATE position (Figure 24-2) .
FUEL TANK
See General Warnings on page 1-2.
GENERAL INFORMATION
The vehicle is equipped with a high impact plastic, 6.7 gallon (25.4 L) fuel tank.
WARNING
• If the fuel tank is damaged, replace it. Do not attempt to repair it. See the following tank removal
and disposal procedure.
CAUTION
• Add only unleaded fuel to the tank. Do not put oil in the fuel tank.
FUEL TANK REMOVAL
1. Place the Forward/Reverse handle in the NEUTRAL position and the neutral lockout cam in the MAINTENANCE
position.
2. Turn fuel shut-off valve to the closed (OFF) position and run the engine until fuel remaining in the carburetor, fuel
pump, and fuel lines is used up and the engine stalls
(Figure 22-13, Page 22-21) .
3. Turn the key switch to the OFF position and remove the key, place the Forward/Reverse handle in the NEUTRAL
position, and chock the wheels.
4. Disconnect battery. See Disconnecting the Battery – Gasoline Vehicles on page 1-3.
5. Return the neutral lockout cam to the OPERATE position.
6. Loosen, but do not remove, the carburetor drain screw (11) and drain fuel remaining in the carburetor bowl into an
approved container
(Figure 22-4, Page 22-4) . Retighten carburetor drain screw.
7. Using a siphon with a suction device, siphon all fuel out of the tank and into an approved container. See
following DANGER and WARNING.
2014 Precedent ® Golf Car Maintenance and Service Manual Page 22-17