Club Car Precedent 2014, Руководство по техническому обслуживанию и ремонту

Страница: 253 / 548

SECTION 18 – TRANSAXLE: ELECTRIC VEHICLE
18
DANGER
• See General Warnings on page 1-2.
WARNING
• See General Warnings on page 1-2.
LUBRICATION
See General Warnings on page 1-2.
There are two plugs located on the lower half of the transaxle housing. The upper plug (21) (as viewed when the
vehicle is on a level surface) is used as a lubricant level indicator
(Figure 18-5, Page 18-3) . When the vehicle
is parked on a level surface, the lubricant level should be even with the bottom of the hole. The lower plug (22) is
for draining the lubricant. When draining the lubricant, the upper plug should be removed so the lubricant will drain
faster. Be sure the drain plug is installed before filling.
See following NOTE.
NOTE: Recycle or dispose of used oil or lubricant in accordance with local, state, and federal regulations.
AXLE BEARING AND SHAFT
See General Warnings on page 1-2.
AXLE SHAFT
Axle Shaft and Oil Seal Removal
1. Disconnect the batteries and discharge the controller. See Disconnecting the Batteries – Electric Vehicles
on page 1-4.
2. Place chocks at the front wheels. Loosen lug nuts on rear wheels and lift the rear of the vehicle with a chain
hoist or floor jack. Place jack stands under the axle tubes to support the vehicle.
See WARNING “Lift only one
end...” in General Warnings on page 1-2.
3. Remove the rear wheel and brake drum. See Section 6 – Wheel Brake Assemblies. See Section 8 – Wheels and
Tires.
4. Use 90° internal snap ring pliers to remove the internal retaining ring (6) from the axle tube (Figure 18-5, Page
18-3) . See also Figure 18-1, Page 18-2.
5. Remove the axle, retaining ring, and bearing assembly by pulling the axle straight out of the housing.
6. If necessary, remove the axle oil seal and adapter ring.
6.1. Use a bearing puller (P/N 1016417) to remove the axle seal and adapter ring from the axle tube (Figure
18-2, Page 18-2) . See following CAUTION and NOTE.
2014 Precedent ® Golf Car Maintenance and Service Manual Page 18-1