877-973-3486
AWE 00192 Rev. 000
20
ACTT Xspotter Service Manual
Starter
• Inspect for secure mounting and evidence
of cracks.
• Check routing and clamping of cables
(Figure 19).
Figure 19
Transmission Mounts
• Check the transmission mounts for cracks.
Check that all fasteners are tightened
to proper torque. Refer to the
“Special
Torque Chart”
in this manual.
Exhaust System
• Check exhaust system condition and
mounting.
• Verify all exhaust insulation blankets are
in condition and installed correctly,
(if
equipped).
Lubrication
Driveline Lubrication
Note: Refer to the axle manufacturers’
documentation for recommended
lubricants, change intervals and service
specifications.
WARNING
To rotate the driveline, the drive wheels
must be elevated, the transmission in
neutral and the parking brake released.
Ensure front wheels are securely
chocked before elevating the drive
wheels. ABS must be deactivated before
lifting/rotating wheels.
• Perform chassis lubrication per the
“Chassis Lubrication Chart”
in this
manual. For chassis lubrication use Delo
Grease EP NLGI 1 and 2 (minimum) or
equivalent. Be sure that grease fittings
are clean and free from debris prior to
application of grease. Ensure that each
grease fitting fills with grease when
lubricated. Remove excess grease from
fittings, spring shackles and other surfaces.
Inspect fittings for evidence of leaks.
• Lubricate boom lift cylinder pivot pins.
• Lubricate the upper fifth wheel surface.
• Lubricate U-joints, slip yokes and carrier
bearings (Figure 20).
Note: When greasing U-joints, enough
grease should be applied so that the old
grease and impurities are forced out past
the seals. If grease does not squeeze out
of a seal, press the shaft toward the seal
and apply grease at full pressure. Ensure
grease is expelled from all four trunnions
before proceeding.
Содержание ACTT Xspotter 2018
Страница 1: ...autocartruck com Preventive Maintenance AWE 00006 Rev 005a ACTT Service Manual ...
Страница 2: ......
Страница 4: ...This page left blank intentionally ...
Страница 59: ......