![background image](http://html.mh-extra.com/html/thermo-king/super-ii-sr/super-ii-sr_manual_1104381057.webp)
Electrical Maintenance (Rev 6/98)
47
A code 02 (coil sensor fault) is a faulty evaporator coil sen-
sor. If the evaporator coil sensor fails during defrost, the
microprocessor defrost timer automatically terminates
DEFROST in 30 or 45 minutes. Test the evaporator coil
sensor. Repair or replace the evaporator coil sensor or
microprocessor.
Air Switch Testing And Adjustment
Before testing or adjusting the air switch, check the clear
plastic tubing and black plastic tubing to the evaporator coil.
Be sure they are not obstructed or crushed. Check the
probes in the evaporator housing to be sure they are in the
proper position and make sure they are not obstructed.
1.
Remove the spastic sensing tubing from both sides of
the air switch.
2.
Disconnect one wire at the switch terminal. Connect a
test light or continuity tester to the two terminals used
on the switch.
3.
Connect the test equipment (TK 204-442 and TK 204-
494) to the hose fitting on the side of the air switch
stamped BLACK.
Air Switch Test
4.
Pressurize the hose until the continuity tester indicates
a completed circuit. Now read the dial of the test gauge.
This is the setpoint of the air switch (correct reading is
35.6 ± 2 mm (1.4 ± 0.08 in.) H
2
0. Release the pressure.
5.
If the switch is out of calibration, pressurize the hose
again until the tester indicates 35.6 mm (1.4 in.) H
2
0.
Turn the adjustment screw clockwise or counterclock-
wise until the switch closes and the continuity tester
1.
Continuity Tester
2.
Adjustment Screw
3.
Squeeze Bulb (P/N 204-494)
4.
Pressure in Inches of Water (P/N 204-442)
Summary of Contents for Super II SR+
