121
Mechanical Diagnosis
CONDITION
POSSIBLE CAUSE
REMEDY
Unit switch ON—LCD blank or
backlight does not come on
Battery discharged
Charge or replace battery
Faulty battery cable connections
Clean battery cables
Fuse blown
Check for short circuit in unit wiring
Unit switch ON and LCD backlight
ON but engine will not crank
Batteries discharged
Replace or recharge battery
Defective Preheat-Start switch
Replace switch
Defective starter solenoid
Replace solenoid
Corroded battery connections
Clean and tighten
Defective starter
Repair starter
Water in cylinders
Check for hydrostatic lock. Remove
glow plugs and turn engine slowly
Starter motor turns but engine
does not crank
Starter clutch defective
Replace
Engine cranks but fails to start
Fuel solenoid valve defective or
stuck
Replace
Fuel injection pump defective
Replace pump
Glow plugs defective
Replace defective glow plugs
No fuel or wrong fuel
Fill with proper fuel
Fuel pump defective
Replace pump
Air in fuel system
Bleed air
Compression low
Overhaul engine
Injection nozzles defective
Replace nozzles
Incorrect timing
Adjust timing
Air cleaner clogged
Replace air filter
Defective HPCO
Replace HPCO
Engine stops after starting
Air in injection pump
Bleed fuel system
Fuel filter obstructed
Replace filter element
High head pressure
Eliminate cause of high head
pressure
Vent of fuel tank obstructed
Unclog vent
Summary of Contents for Super II SR+
