![background image](http://html.mh-extra.com/html/thermo-king/super-ii-sr/super-ii-sr_manual_1104381080.webp)
Engine Maintenance (Rev 6/98)
70
CAUTION: Do not attempt to adjust belts with the
unit running.
CAUTION: With the On-Off switch in the ON
position, the unit may start operation at any time
without prior warning. Switch the unit On-Off switch to
the OFF position before performing maintenance or
repair procedures.
Alternator Belt Adjustment
The alternator belt tension should read 35 on the belt ten-
sion gauge.
1.
Loosen the alternator pivot bolt and the adjusting arm
bolt.
2.
Move the alternator on the adjusting arm slot to adjust
the belt to 35 on the belt tension gauge.
3.
Tighten the adjusting arm bolt and alternator pivot bolt.
Fan Belt Adjustment
The fan belt tension should read 72 on the belt tension
gauge.
1.
Remove the lower belt guard.
2.
Loosen the lower idler assembly.
3.
To increase the belt tension, pry upward on the idler
pulley. Hold the tension on the pulley and torque the
bolt to 54 N•m (40 ft-lb).
NOTE: Make sure to position the belt guide properly
when tightening the lower idler.
4.
Install the lower belt guard.
Proper Belt Guide Position
Fan Belt Replacement
1.
For better access to the fan belt, remove the grille and
orifice assembly.
2.
Remove the lower belt guard.
3.
Loosen (or remove) the lower idler pulley.
4.
Swing the control box assembly out to access the
engine pulley.
5.
Remove the fan belt (through the notch in the fan spin-
ning).
6.
Install and adjust the new fan belt.
7.
Fasten the control box back in place.
8.
Install the belt guard.
9.
Install the grille and orifice assembly.
1.6 mm
(1/16 in.)
1.6 mm
(1/16 in.)
AEA1373
Summary of Contents for Super II SR+
