9-1
BLZZRD
™
Portable Refrigerated Sampler
Section 9 Maintenance
This section describes how to maintain and troubleshoot your
BLZZRD. If you think your unit requires repair, or if you have
questions concerning its operation or maintenance, contact
Teledyne ISCO’s Technical Service Department:
Phone: (866) 298-6174
(402) 464-0231
FAX: (402) 465-3001
E-mail:[email protected]
9.1 Maintenance
Checklist
Before each use:
•
Inspect the pump tube for wear. Replace it if necessary.
•
Clean the pump tubing housing.
•
Change the suction line if necessary.
•
Clean the bottles, suction line, strainer and pump tube.
•
Check the humidity indicator.
•
Defrost the refrigerator compartment if necessary.
Every five years:
• Replace the controller’s internal battery.
9.2 Cleaning Guidelines
Keeping the sampler clean and protected from harsh elements
may extend the usable life of the sampler. The following cleaning
instructions can be performed as needed.
9.2.1 Cleaning the BLZZRD
Exterior
The BLZZRD controller and refrigerator exterior may be cleaned
with warm soapy water and a rag. Never use acids or solvents to
clean the sampler. If there is excessive dirt and debris, the
sampler may be hosed off with water. Do not use a pressure
washer; this may force water past the protective seals.
CAUTION
Do not tip the sampler on its side or completely upside-down.
Positions other than the sampler‘s normal upright position may
cause oil to run into the compressor inlet, which can perma-
nently damage the cooling system. If the sampler is tipped or
turned over, the sampler‘s refrigeration system must not be
operated for at least one hour after returning the sampler to its
upright position.
Summary of Contents for Everywhereyoulook BLZZRD
