22
22
Section 2 - Stripe Hog Systems
WARNING
ENTERING THE WATER TANKS CAN BE DANGEROUS,
PARTICULARLY IN HOT WEATHER. PERSONNEL ENTERING
THE TANK ARE SUBJECT TO SLIPS AND FALLS, POOR
VENTILATION, HEAT EXHAUSTION, OR OTHER INJURIES
COMMON TO WORKING IN CONFINED SPACES WITH LIMITED
VENTILATION. NO ONE SHOULD ENTER THE FRESHWATER
TANKS WITHOUT NOTIFYING A COWORKER OR ANOTHER
PERSON FIRST. THE PERSON WORKING INSIDE THE TANK
SHOULD ALSO KEEP THE TRUCK IGNITION KEYS WITH HIM
TO ENSURE THE UNIT CANNOT BE ACCIDENTALLY DRIVEN
WITH HIM OR HER INSIDE. ANOTHER TEAM MEMBER
SHOULD ALWAYS STAY IN CONSTANT COMMUNICATION
WITH THE PERSON INSIDE THE TANK TO ENSURE THEY
ARE SAFE AND BE ABLE TO PROVIDE ASSISTANCE IF
NECESSARY.
Charge Water Pump
The water tanks provide clean fresh water to the
low pressure charge pump. It is powered by the
water blasting accessory hydraulic system. The
pump delivers a constant supply of water to the
Ultra-High Pressure (UHP) Pump and should main-
tain a minimum of at least 40 PSI (2.8 Bar) on
the Charge Pressure gauge in the control panel.
A supply valve located between the clean water
tank and the charge water pump controls the flow
of water. Always make sure there is at least a half
a tank of water and the supply valve is open prior
to engaging the charge water pump. If the charge
water pump is engaged while this valve is closed or
there is no water in the clean water tank, you will
not be able to achieve required UHP pump charge
water pressure and the charge pump impeller or
UHP pump will likely be damaged.
Note:
The UHP pump can cavitate if the charge wa-
ter pressure drops below 25 PSI (1.7 Bar.)
Cavitation can cause severe damage to the
UHP pump and should never be allowed to
occur. You should always monitor the charge
water pressure and never operate the UHP
pump when charge water pressure drops
below 30 PSI (2.1 Bar.)
The charge water pump is activated by start-
ing the auxiliary engine and pressing the rocker
switch labeled CHARGE PUMP on the control panel.
(Refer to Startup Procedure in the Waterblasting
Operation section of this manual) Once activated,
a green light will illuminate to confirm the charge
Clean Water Tank Man-Way Hatch
Charge Water Pump Supply & Drain Valves
Charge Water Pump
Summary of Contents for SK5500
