49
49
Section 2 - Stripe Hog Systems
Filter Bag
The filter bag is biodegradable and designed to
slide out of the tank with the debris during dump-
ing. When installing a new bag, make sure to
attach the loops at the top of the filter bag to the
sliding rods on each side of the tank. The rods
hold the bag in position during operation and are
designed to automatically slide out with the bag
and debris during dumping. When installing a
new filter bag, make sure it is installed properly.
The bag will not stay in the proper position during
operation and may not release properly during
dumping if it is not installed properly.
Filtered wastewater is usually clean enough to
dump in swales alongside the road, vacant fields
and designated areas at airports. It should never
be dumped directly into lakes and ponds or any
standing water. Always check with the authorities
to ensure you are dumping within local guidelines.
WARNING
A N I M P R O P E R LY I N S TA L L E D D E B R I S B A G M AY N O T
RELEASE PROPERLY DURING DUMPING. THIS CAN CAUSE
THE LINER TO SEPARATE FROM THE DEBRIS TANK,
DAMAGING THE TANK AND/OR CAUSE SEVERE INJURY TO
PERSONNEL. ALWAYS MAKE SURE THE DEBRIS BAG IS
INSTALLED PROPERLY AND THAT ALL PERSONNEL STAY
WELL CLEAR OF THE TRUCK AND DEBRIS TANK DOOR
WHEN DUMPING OPERATIONS ARE UNDERWAY.
WARNING
NEVER ROCK OR JERK THE DEBRIS TANK UP AND DOWN
TO DISLODGE MATERIAL STUCK IN THE DEBRIS TANK.
THIS CAN CAUSE THE HYDRAULIC RAM AND/OR OTHER
COMPONENTS TO FAIL WHICH COULD RESULT IN SEVERE
INJURY TO PERSONNEL AND DAMAGE TO THE UNIT.
Gravity Wastewater Drain
Wastewater is drained by gravity by opening the
drain valve located on bottom side of the tank.
To use the gravity drain system, make sure the
vacuum system is shutdown, then open the valve
on the passenger side of the tank. Wastewater will
continuously flow from the tank while the valve
is open. The drain valve system must be moni-
tored periodically during operation and cleaned
as necessary.
Waste Tank Drain Valve
Waste Tank Interior & Slide Rods
Summary of Contents for SK5500
