413-01-14
413-01-14
Instrument Cluster
DIAGNOSIS AND TESTING (Continued)
PINPOINT TEST D: TEMPERATURE GAUGE DOES NOT OPERATE PROPERLY OR ALWAYS INDICATES
H (HOT)
TEST STEP
ACTION TO TAKE
D1 IDENTIFY SYMPTOM
NOTE: Do not carry out the following tests steps if interface adapter
Yes =
GO to D6.
assembly (IAA) module DTC B1834 Gauge Drive Current Fault occurs. If
DTC B1834 occurs, refer to the symptom chart.
•
With key ON, identify the symptom.
•
Does the temperature gauge indicate H (hot)?
No =
GO to D2.
D2 CHECK TEMPERATURE GAUGE
•
Enter the interface adapter assembly (IAA) module active command
Yes =
GO to D3.
mode TEMPERATURE GAUGE and set the active command TEMP G
to 30%.
•
Does the temperature gauge indicate above the C (cold) mark?
No =
GO to D4.
D3 CHECK TEMPERATURE GAUGE FOR CORRECT
TEMPERATURE REGION INDICATION
•
Set the active command TEMP G to the following percentages and
Yes =
System OK. CHECK wiring
verify the temperature gauge operation:
for intermittent connections.
Percentage/Temperature
No =
REPLACE the instrument
cluster.
— 15% = C (cold)
— 35% = Bottom of normal region
— 50% = Midscale
— 65% = Top of normal region
— 75% = H (hot)
•
Is the temperature gauge OK?
D4 CHECK INTERFACE ADAPTER ASSEMBLY (IAA) MODULE
•
Connect 104-Pin Breakout Box (BOB) to the IAA module and IAA
Yes =
REPLACE the IAA module.
module C1945. REFER to
•
With key ON, connect a jumper wire between BOB pins 20 and 75.
No =
GO to D5.
•
Does the temperature gauge indicate greater than H (hot)?
D5 CHECK CIRCUIT 3406 (DG/LG) FOR OPEN
•
With key OFF, disconnect instrument cluster C214 and measure the
Yes =
REPLACE the instrument
resistance of the DG/LG wire between pin 11 on instrument cluster C214
cluster.
and BOB pin 20.
•
Is the resistance less than 5 ohms?
No =
REPAIR the DG/LG wire.
D6 CHECK POWER TO INSTRUMENT CLUSTER
•
With key OFF, disconnect instrument cluster C215.
Yes =
GO to D8.
•
With key ON, measure the voltage between pin 12 (BK/LG wire) on
No =
GO to D7.
instrument cluster C214 and pin 6 (BK/W wire) on instrument cluster
C215.
•
Is the voltage greater than 10 volts?
D7 CHECK GROUND TO INSTRUMENT CLUSTER
•
With key OFF, measure the resistance between pin 6 (BK/W wire) on
Yes =
REPAIR circuit 3049
instrument cluster C215 and ground.
(BK/LG wire).
•
Is the resistance less than 5 ohms?
No =
REPAIR the BK/W wire.
D8 CHECK CIRCUIT 3406 (DG/LG) FOR SHORT TO POWER
•
Connect 104-Pin Breakout Box (BOB) to the IAA module C1945; leave
Yes =
REPAIR the DG/LG wire.
IAA module disconnected.
•
With key ON, measure the voltage between BOB pin 20 and ground
No =
(BOB pin 80).
•
Is the voltage greater than 0 volts?
(Continued)
2001 Ranger EV, 01/2001
Summary of Contents for 2001 Ranger
