412-03-11
412-03-11
Air Conditioning
DIAGNOSIS AND TESTING (Continued)
PINPOINT TEST F: A/C COMPRESSOR DOES NOT OPERATE (NO COOLING)
TEST STEP
ACTION TO TAKE
•
With key OFF, disconnect IAA module from BOB; leave BOB
Yes =
REPLACE the IAA module.
connected to IAA module C1945.
REFER to
•
With key OFF, disconnect A/C inverter motor controller (IMC) C1947
No =
REPAIR the R/PK wire.
and measure the resistance between BOB pin 46 and ground (BOB pin
80).
•
Is the resistance greater than 10,000 ohms?
F9 CHECK CIRCUIT 3026 (R/PK) FOR OPEN
•
With key OFF, disconnect A/C inverter motor controller (IMC) C1947
Yes =
GO to F10.
and measure the resistance of the R/PK wire between pin 8 on A/C IMC
C1947 and BOB pin 46.
•
Is the resistance less than 5 ohms?
No =
REPAIR the R/PK wire.
F10 CHECK HIGH-VOLTAGE POWER TO A/C IMC
•
Disconnect the 12-volt auxiliary battery negative cable.
Yes =
REPLACE the A/C IMC.
•
Remove the high-voltage power distribution box (HVPDB) cover.
No =
GO to F11.
WARNING: The following test steps contain high-voltage
procedures. High-voltage insulated safety gloves and face shield must
be worn when performing the following steps. Failure to follow this
warning may result in severe personal injury or death.
•
Disconnect HVPDB A/C IMC high-voltage C1917F.
•
Reinstall the HVPDB cover.
•
Reconnect the 12-volt auxiliary battery negative cable.
•
With key ON, measure the voltage between circuit 3150 (DB wire) and
circuit 3151 (W wire) on HVPDB A/C IMC high-voltage C1917.
•
Is the voltage greater than 300 volts?
F11 CHECK HIGH-VOLTAGE FUSE
•
With key OFF, disconnect the 12-volt auxiliary battery negative cable.
Yes =
REPLACE the 25A A/C
fuse. GO to F12.
•
Disconnect high-voltage auxiliary load in-line C1935 on the traction
No =
REPLACE the HVPDB.
battery support tray.
REFER to
•
Disconnect all HVPDB high-voltage connectors.
or
•
Disconnect power steering assembly high-voltage C1895.
•
Measure the resistance of the 25A A/C fuse.
•
Is the resistance greater than 1,000 ohms?
F12 CHECK A/C IMC FOR SHORT
•
Connect the Capacitor Discharge Tool to the digital volt/ohmeter
Yes =
REPLACE the A/C IMC.
(DVOM) and set the DVOM to volts.
•
Connect the probes of the Capacitor Discharge Tool to circuit 3150 (DB
No =
GO to F13.
wire) and circuit 3151 (W wire) on HVPDB A/C IMC C1917M and
allow the voltage on the DVOM to discharge to 0 volt.
•
Measure the resistance between circuit 3150 (DB wire) and circuit 3151
(W wire) on HVPDB A/C IMC C1917M.
•
Is the resistance less than 30 ohms?
F13 CHECK HVPDB FOR SHORT
•
Measure the resistance between circuit 3150 (DB wire) and circuit 3151
Yes =
(W wire) on HVPDB A/C IMC high-voltage C1917F.
•
Is the resistance greater than 10,000 ohms?
No =
REPLACE the HVPDB.
REFER to
F14 CHECK SYSTEM
(Continued)
2001 Ranger EV, 01/2001
Summary of Contents for 2001 Ranger
