413-01-12
413-01-12
Instrument Cluster
DIAGNOSIS AND TESTING (Continued)
PINPOINT TEST B: SPEEDOMETER DOES NOT OPERATE OR INDICATES INCORRECT VEHICLE SPEED
TEST STEP
ACTION TO TAKE
•
Enter the TIM active command mode SPEEDOMETER CONTROL and
No =
GO to B4.
set the active command SPDOMETER to 30%.
•
Set the multimeter to the frequency setting and measure the frequency
between BOB pin A7 and ground (BOB pin A29).
•
Is the frequency greater than 70 Hz?
B4 CHECK CIRCUIT 679 (GY/BK) FOR SHORT TO GROUND
•
With key OFF, disconnect BOB from TIM; leave BOB connected to
Yes =
GO to B5.
TIM C4998, C4999.
•
With key OFF, disconnect instrument cluster C214, power steering
No =
REPAIR the GY/BK wire.
assembly C1992, and generic electronic module (GEM) C224.
•
With key OFF, measure the resistance between BOB pin A7 and ground
(BOB pin A29).
•
Is the resistance greater than 10,000 ohms?
B5 CIRCUIT 679 (GY/BK) FOR SHORT TO POWER
•
With key ON, measure the voltage between BOB pin A7 and ground
Yes =
REPAIR the GY/BK wire.
(BOB pin A29).
•
Is the voltage greater than 0 volts?
No =
REPLACE the TIM. REFER
B6 CHECK CIRCUIT 679 (GY/BK) FOR OPEN
•
With key OFF, disconnect instrument cluster C214.
Yes =
GO to B7.
•
Enter the TIM active command mode SPEEDOMETER CONTROL and
No =
REPAIR the GY/BK wire
set the active command SPDOMETER to 30%.
between instrument cluster
•
Set the multimeter to the frequency setting and measure the frequency
C214 and TIM C4998.
between pin 14 (GY/BK wire) on instrument cluster C214 and ground.
•
Is the frequency greater than 70 Hz?
B7 CHECK POWER TO INSTRUMENT CLUSTER
•
With key OFF, disconnect instrument cluster C215 and C216.
Yes =
REPLACE the instrument
cluster.
•
With key ON, measure the voltage between pin 9 (LB wire) on
No =
GO to B8.
instrument cluster C216 and pin 6 (BK/W wire) on instrument cluster
C215.
•
Is the voltage greater than 10 volts?
B8 CHECK GROUND TO INSTRUMENT CLUSTER
•
With key OFF, measure the resistance between pin 6 (BK/W wire) on
Yes =
REPAIR circuit 742 (LB
instrument cluster C215 and ground.
wire).
•
Is the resistance less than 5 ohms?
No =
REPAIR the BK/W wire.
PINPOINT TEST C: TRACTION BATTERY STATE OF CHARGE (SOC) GAUGE DOES NOT OPERATE,
INDICATES THE INCORRECT SOC, OR ALWAYS INDICATES F (FULL)
TEST STEP
ACTION TO TAKE
C1 IDENTIFY SYMPTOM
NOTE: Do not carry out the following tests steps if interface adapter
Yes =
assembly (IAA) module DTC B1834 Gauge Drive Current Fault occurs. If
DTC B1834 occurs, refer to the symptom chart.
•
With key ON, identify the symptom.
•
Does the traction battery state of charge (SOC) gauge indicate F
No =
GO to C2.
(full)?
C2 CHECK TRACTION BATTERY STATE OF CHARGE (SOC)
GAUGE
(Continued)
2001 Ranger EV, 01/2001
Summary of Contents for 2001 Ranger
