413-01-33
413-01-33
Instrument Cluster
DIAGNOSIS AND TESTING (Continued)
PINPOINT TEST Y: DOOR AJAR INDICATOR DOES NOT OPERATE PROPERLY
TEST STEP
ACTION TO TAKE
•
With key ON, measure the voltage between pin 1 (LB wire), pin 12 (LB
Yes =
GO to Y6.
wire) on instrument cluster C215 and ground.
•
Is the voltage greater than 10 volts?
No =
REPAIR the LB wire(s) in
question.
Y6 CHECK CIRCUIT 627 (BK/O) FOR OPEN
•
With key OFF, disconnect GEM C221 and measure the resistance of the
Yes =
GO to Y7.
BK/O wire between pin 9 on instrument cluster C215 and pin 9 on GEM
C221.
•
Is the resistance less than 5 ohms?
No =
REPAIR the BK/O wire.
Y7 CHECK CIRCUIT 627 (BK/O) FOR SHORT TO GROUND
•
With key OFF, measure the resistance between pin 9 (BK/O wire) on
Yes =
REPLACE the GEM.
instrument cluster C215 and ground. REFER to
Section 419-10 of
the 2001 Ranger Workshop
Manual.
CLEAR the DTCs.
•
Is the resistance greater than 10,000 ohms?
No =
REPAIR the BK/O wire.
Y8 CHECK DOOR AJAR INDICATOR CONTROL CIRCUIT FOR
SHORT TO POWER
•
With key OFF, disconnect instrument cluster C215.
Yes =
GO to Y9.
•
With key ON, measure the voltage between pin 9 (BK/O wire) on
No =
REPLACE the instrument
instrument cluster C215 and ground.
cluster.
•
Is the voltage greater than 0 volts?
Y9 CHECK CIRCUIT 627 (BK/O) FOR SHORT TO POWER
•
With key OFF, disconnect GEM C221.
Yes =
REPAIR the BK/O wire.
•
With key ON, measure the voltage between pin 9 (BK/O wire) on
No =
REPLACE the GEM;
instrument cluster C215 and ground. REFER to
Section 419-10 of
•
Is the voltage greater than 0 volts?
the 2001 Ranger Workshop
Manual.
PINPOINT TEST Z: SEAT BELT INDICATOR DOES NOT OPERATE PROPERLY
TEST STEP
ACTION TO TAKE
Z1 CHECK IGNITION SWITCH STATES
•
Use New Generation STAR (NGS) Tester to monitor the PID
Yes =
GO to Z2.
IGN GEM while turning the ignition switch through the START, RUN,
OFF, and ACC positions.
•
Do the PID values agree with the ignition switch position? No = REFER to
Section 417-02 of
the 2001 Ranger Workshop
Manual.
Z2 RETRIEVE DIAGNOSTIC TROUBLE CODES (DTCs)
•
Retrieve and document continuous DTCs, clear continuous DTCs, and
Yes =
If DTC B1426, GO to Z9.
carry out on-demand self-test.
If DTC B1428, GO to Z3.
If DTCs B1430 and B1462,
REFER to
Section 413-09 of
the 2001 Workshop Manual.
If DTC B1342, REPLACE
the GEM; REFER to
Section 419-10 of the 2001
Ranger Workshop Manual.
CLEAR the DTCs.
•
Are any DTCs recorded?
No =
GO to Z3.
Z3 VERIFY SEAT BELT WARNING CHIME OPERATION
(Continued)
2001 Ranger EV, 01/2001
Summary of Contents for 2001 Ranger
