413-01-15
413-01-15
Instrument Cluster
DIAGNOSIS AND TESTING (Continued)
PINPOINT TEST D: TEMPERATURE GAUGE DOES NOT OPERATE PROPERLY OR ALWAYS INDICATES
H (HOT)
TEST STEP
ACTION TO TAKE
D9 CHECK INSTRUMENT CLUSTER
•
With key OFF, reconnect instrument cluster C214, C215. Yes = REPLACE the IAA module.
•
With key OFF, connect BOB to IAA module; leave BOB connected to
No =
REPLACE the instrument
IAA module C1945.
cluster.
•
With key ON, connect a jumper wire between BOB pin 20 and ground
(BOB pin 80).
•
Does the temperature gauge indicate C (cold)?
PINPOINT TEST E: ECONOMY GAUGE DOES NOT OPERATE PROPERLY OR ALWAYS IND
(POSITIVE)
TEST STEP
ACTION TO TAKE
E1 IDENTIFY SYMPTOM
NOTE: Do not carry out the following tests steps if interface adapter
Yes =
GO to E6.
assembly (IAA) module DTC B1834 Gauge Drive Current Fault occurs. If
DTC B1834 occurs, refer to the symptom chart.
•
With key ON, identify the symptom.
•
Does the economy gauge in (positive)?
No =
GO to E2.
E2 CHECK ECONOMY GAUGE
•
Enter the interface adapter assembly (IAA) module active command
Yes =
GO to E3.
mode ECONOMY GAUGE and set the active command ECON G to
30%.
•
Does the economy gauge indicate above the - (negative) mark?
No =
GO to E4.
E3 CHECK ECONOMY GAUGE FOR CORRECT INDICATION
•
Set the active command ECON G to the following percentages and
Yes =
System OK. CHECK wiring
verify the economy gauge operation:
for intermittent connections.
Percentage/Gauge Indication
No =
REPLACE the instrument
cluster.
— 20% = - (Negative) mark
— 35% = 0.25 position
— 55% = Midscale position
— 70% = 0.75 position
— 80% = + (Positive) mark
•
Is the economy gauge OK?
E4 CHECK INTERFACE ADAPTER ASSEMBLY (IAA) MODULE
•
Connect 104-Pin Breakout Box (BOB) to the IAA module and IAA
Yes =
REPLACE the IAA module.
module C1945. REFER to
•
With key ON, connect a jumper wire between BOB pins 22 and 75.
No =
GO to E5.
•
Does the economy gauge indicate greater than + (positive)?
E5 CHECK CIRCUIT 3408 (DB/O) FOR OPEN
•
With key OFF, disconnect instrument cluster C214 and measure the
Yes =
REPLACE the instrument
resistance of the DB/O wire between pin 15 on instrument cluster C214
cluster.
and BOB pin 22.
•
Is the resistance less than 5 ohms?
No =
REPAIR the DB/O wire.
E6 CHECK POWER TO INSTRUMENT CLUSTER
•
With key OFF, disconnect instrument cluster C215 and C216.
Yes =
•
With key ON, measure the voltage between pin 4 (Y wire) on instrument No =
cluster C216 and pin 6 (BK/W wire) on instrument cluster C215.
•
Is the voltage greater than 10 volts?
(Continued)
2001 Ranger EV, 01/2001
Summary of Contents for 2001 Ranger
