J&J Amusements King Scorpion, Руководство по обслуживанию

Страница: 24 / 272

0-18
PROPER CARE IN THE “OFF SEASON”:
Some go-kart tracks do not operate all year long. For this reason, J&J Inc. has prepared this information on how to properly
condition your go-kart fleet for periods of storage or inactivity. We urge you to follow the simple instructions and advice
contained here, referencing specific model information from your owners service manual to maintain the highest level of
safety and preserve the value of your investment.
OIL CHANGE:
Change the engine and reduction case oil, follow the viscosity chart in your owner/service manual. Start engine and allow
the clean oil to circulate throughout engine for approximately 3 minutes. Remove spark plug and pour about a tablespoon
of clean engine oil into the cylinder. Crank engine several revolutions to distribute oil, then reinstall spark plug.
BRAKE FLUID:
If the annual brake fluid change has not been performed recently, it is advisable to change the brake fluid, as contaminated
fluid will cause corrosion and deterioration of the hydraulic brake system. Fluid should be light amber in color. If it is dark
or cloudy, the system must be flushed and fluid renewed.
FUEL TANK:
Drain the fuel tank to remove any moisture or contaminants. Clean and drain carburetor float bowl before storing to
prevent deposits caused by fuel that evaporates over time.
CLEANING AND WAXING:
Storing a dirty go-kart can lead to corrosion, because dirt retains moisture. Thoroughly wash and dry go-kart. Polish and
wax all painted/gelcoat surfaces. Spray the unpainted castings such as engine, reduction gear case, spindles and related
hardware with a corrosion protectant to retard corrosion and rust.
TIRES:
Inflate tires to the recommended pressures and inspect.
CHASSIS LUBRICATION:
Grease spindles, axle bearings, rod ends, throttle arm pivot and pedal pivots to purge any water or contaminants from
these pivot points. Treat other pivots, when no grease fittings are provided, with water-displacing light lubricant spray.
STORAGE AREA AND COVERING:
Select a storage area such as a garage or storage room that is free from dampness and high humidity. The daily temperature
change should be minimal. Do not store in direct sunlight, open flames or sparks. Selecting the proper cover is important.
An unvented, airtight cover may lead to corrosion and rust due to trapped moisture/vapor. Use a vented cover, which will
allow moisture to escape rather than retaining it.
< WARNING > Gasoline is extremely flammable and can be explosive under certain conditions. Make sure the area is
well ventilated and free from any source of flame or sparks.
GO-KART SEASONAL STORAGE (GAS)