Iseki TJ75, Operation Manual

Page: 86 / 117

LUBRICATION & PERIODIC MAINTENANCE
85
ELECTRICAL SYSTEM
Battery
FIG. 6-28: Battery, 1, is located under engine hood in
front of radiator. If battery requires only minor servicing
or charging, it is recommended to remove the front grille
and the side cover to access battery.
When battery removal, electrolyte inspection or cable
cleaning is necessary, front grille must be removed from
Tractor.
Keep top of battery clean and ensure cable connections
are clean and tight. Debris on battery can cause
discharge of battery and possible source of fire.
CAUTION: Batteries produce explosive
hydrogen gas when charged. Keep all
sparks and open flame away from battery.
When necessary to disconnect battery
cables, always disconnect the grounded (-)
cable first to prevent short circuits.
Batteries contain sulfuric acid electrolyte
(fluid). Wear eye and face protection. If
electrolyte comes in contact with skin
or clothes, wash immediately. Contact
physician if electrolyte is ingested or gets
in eyes.
FIG. 6-29,30: Tractors are shipped with battery installed.
If battery replacement should become necessary,
disconnect negative (-) cable, 1, first and then remove
positive (+) cable, 2. Loosen and remove battery
securing clamp and carefully remove battery from
Tractor.
When installing battery, cable, 2, connected to starter
solenoid should be connected to positive (+) battery
terminal first then cable, 1, grounded to Tractor frame
can be connected to negative (-) battery terminal.
NOTE: Make sure replacement battery is of identical
size and equal capacity.
IMPORTANT: Do not reverse battery cable connections
as severe electrical system damage will
result.
FIG. 6-28
1
FIG. 6-29
1
FIG. 6-30
2