Section 03
ENGINE
Subsection 02
(TROUBLESHOOTING)
VMR2004_006_03_02A.FM
03-02-3
LUBRICATION
7. Check battery.
a. Battery shows less power.
Charge battery.
b. Battery has electrical failure.
Replace battery.
8. Check condition of fuse(s).
a. Faulty fuse(s).
Replace.
9. Check Trigger coil for damage and/or electrical failure.
a. Connector is corroded.
Clean and reconnect.
b. Resistance value is out of specification
(refer to TECHNICAL DATA).
Replace trigger coil.
SYMPTOM
NO SPARK.
CONDITION
NORMAL USE.
SYMPTOM
LOW OR NO OIL PRESSURE
CONDITION
NORMAL USE.
Test/Inspection
1. Check oil level and search for leakage on crankcase and/or defective gaskets.
a. Crankcase is leaking due to damage.
Rebuild engine with new crankcase and gasket parts.
Use Bombardier recommended oil (refer to TECHNICAL DATA).
b. Crankcase is leaking due to loose screws.
Retighten screws with recommended torque.
c. Sealing rings, O-rings and/or gaskets are brittle and/or hard or damaged.
Replace damaged parts.
2. Check oil drain plug on engine bottom.
a. Plug is loosed and/or gasket ring is missing.
Retighten the plug and/or place gasket ring.
3. Check oil strainer cover on engine bottom.
a. Screw(s) is(are) loose and/or gasket is damaged, brittle or hard.
Retighten screws and/or replace gasket.
4. Check weep hole if oil leaks.
a. Oil leaking from weep hole means a damaged oil seal on water pump shaft.
Replace oil seal (refer to COOLING SYSTEM and MAGNETO COVER).
5. Check oil pressure switch function.
a. Oil pressure switch damaged.
Replace oil pressure switch.
Summary of Contents for DS 650
Page 1: ......
Page 2: ...Shop Manual 2004 DS 650TM DS 650TM BAJA DS 650TM BAJA X ...
