ApenGroup AQUAKOND AKY, Installation And Maintenance Manual

Page: 8 / 44

CONDENSATION BOILER
AQUAKOND AKY
8
code HC0048.01GB ed.B-1406
AKY
2.3. Power Supply
The heater shall be properly wired to an efficient grounding
system, complying with the laws of the Country where the ap-
pliance is installed.
Warning
• Check the efficiency of grounding system with the help of
qualified personnel.
• Make sure network wire gauge suits the unit rated input
shown on rating plate and in this Manual.
• Keep neutral wire separate from phase wire. The unit can
be plugged into mains using a plug-socket only if the latter
prevents any mix up of phase and neutral wires.
• The system wire gauge in general, and cable section in
particular, must suit the unit rated input shown on equip-
ment data plate and in this Manual.
• Keep cables and wires away from heat sources.
I
mportant: A multi-pole power switch with a switch-contact
gap of at least 3 mm should be installed before the sup-
ply cable. The switch must be in a visible and accessible
position and within 3 meters from the unit. Any installation
or maintenance operation concerning the electrical system
must be accomplished by qualified personnel.
2.4. Use
Children and inexperienced people shall not be allowed to use
any electrical appliance.
The following precautions shall be adopted:
• Do not touch the unit with wet or damp parts of the body
• and/or barefoot;
• Do not use gas pipes to ground electric devices;
• Do not touch hot surfaces of the unit, such as flue pipes;
• Do not put any objects on the unit;
• Do not touch moving parts of the unit.
2.5. Maintenance
Before running any servicing or cleaning, disconnect power and
gas supply by means of main ON/OFF switch and/or appropri-
ate detection devices.
In case of failure and/or insufficient running standards, switch
off the unit and do not attempt to repair it yourself. Contact the
local authorized Service Centre.
Only use original spare parts for repairs. Failure to follow above
instructions could compromise the unit safety and shall void
the warranty.
If the unit is not used for long periods, shut the gas off through
gas cocks and disconnect the unit from power supply.
I
f the unit is to be definitively decommissioned, in addition
to above suggestions, any potential source of hazard shall
have to be made inoffensive.
W
arning: To properly and safely
operate the equipment, glycol shall
be added to water in the hydraulic circuit in
required percentage according to minimum
temperatures reached in the installation
area.
D
O NOT permanently connect circuit inlet
to water mains
.
For its AKY boilers, Apen Group tested and recommends
ALPHI 11 glycol manufactured by Fernox. The following
kits can be ordered:
code content
C07200-05 5 litres
C07200-25 25 litres
Safety and health guidelines for the use of
glycol
If ingested in high quantity, glycol can central
nervous system depression, kidney and
liver injury and respiratory problems. Avoid
contact with skin and eyes and protect upper
respiratory tract.
Avoid release to the environment since glycol
can pollute surface and underground water
and the soil.
Wear rubber gloves and boots and standard
protective clothes. Wear safety glasses.
For more information, read safety sheet by
Cookson Electronics, Alpha Metals S.p.A.,
Via Ghisalba 1, 20021 Bollate (Italy)
Ph: +39.02.383311 Fax: +39.02.38300398
email: fernox_italy@cooksonelectronics.
com www.fernox.com