Suitmate Swimsuit Water Extractor, Инструкция по установке и обслуживанию, Страница: 15 / 72

April 13, 2009 115-V 20-Amp 60-Hz Self-Timed Unit
13
MAINTENANCE INSTRUCTIONS
115-V 20-Amp 60-Hz Self-Timed Unit
These recommendations are designed to keep your SUITMATE
®
unit clean and operating properly. Extractor
Corporation recommends that these procedures be followed at the suggested frequencies.
TWICE DAILY
1) Hygienic Wipes
Use a disinfectant wipe, such as the PDI Sani-cloth
®
or Clorox
®
Disinfecting Wipes to wipe down the inside of
the Basket, the Black Plastic Top, the Lid, and the sides of the unit.
DAILY
1) Inspection
a. Open the Lid, pull the Basket to the side and with a flashlight, check for trapped debris such a
straps, strings, bathing caps, etc. inside of the unit. If foreign objects and/or debris are found, remove
them with a long hook or other implement.
b. Should the Basket “flop” to one side during this inspection, you may have a broken shock mount in
which you can contact Extractor Corporation at 800-553-3353 for further assistance.
c. Press down on the Lid and run the machine to ensure that it is operating properly. When you lift the
Lid, the Basket should stop spinning within one (1) second.
2) Hygienic Cleaning
a. Mix a bleach-based disinfecting concentrate at the manufacturer’s recommended strength in a
½ gallon bucket of water.
b. Clean the inside of the unit by spinning a small soft towel soaked in the cleaner. Repeat this
step 3 times.
c. The spun towel can then be used to wipe down the Basket, the Black Plastic Top, the Lid, and the
sides of the unit.
d. Re-wipe the surfaces (Basket, Black Plastic Top, Lid, and the exterior of the unit) with a fresh towel
and clean water.
WARNING!
Never use flammable solvents in or on the SUITMATE
®
unit.
When cleaning around the unit, be careful not to allow water to splash up under
the unit as this may damage the motor.
3) Flushing
a. If your unit uses a drain house or a P-trap, disconnect it from the unit’s drain tailpiece and inspect it
for any obstructions.
b. With the drain hose or P-trap removed, place an empty bucket (1-2 gallons) under the tailpiece to
catch the discharge from the flush.
c. Mix a disinfecting cleaner by referring back to steps A and B under Hygienic Cleaning.
d. SLOWLY pour the cleaner into the top opening of the unit. If the unit’s drainage channels are open,
the full amount of cleaner solution poured into the unit should flow into the bucket below within a few
seconds. Check the discharge water for signs of debris.
e. Repeat step D using clean water until a free flow of water is established and the discharge water
is clear of debris.
WWW.RESTROOMDIRECT.COM 704•937•2673 129 Oakpark Dr., Unit A, Mooresville, NC 28115