Section 05 ELECTRICAL SYSTEM
Subsection 05 (STARTING SYSTEM)
Disconnect starter power cable.
Remove starter retaining screws.
smr2007-025-008_a
TYPICAL — REAR OF WATERCRAFT IN ON RH SIDE OF
ILLUSTRATION
1. Exhaust manifold
2. Starter
3. Starter retaining screws
4. Starter power cable retaining nut
Starter Gear Removal
Remove starter.
Remove gear retaining circlip and pull out starter
gear.
1
F18H0NA
2
1. Retaining circlip
2. Starter gear
Starter Gear Installation
Installation is the reverse of removal procedure.
However, pay particular attention to the following.
Use a new circlip.
Starter Installation
Installation is the reverse of the removal proce-
dure. However, pay particular attention to the fol-
lowing.
Ensure starter and engine mating surfaces are
free of debris. Serious problems may arise if
starter is not properly aligned.
Apply
ISOFLEX GREASE TOPAS NB 52 (P/N 293 550
021)
on starter O-rings.
smr2007-025-009_a
1. Apply Isoflex grease Topas NB 52
Install starter.
NOTE:
If starter does not mesh properly with
the intermediate gear: Pull starter out, slightly
rotate the starter gear then reinstall the starter.
Temporarily removing both O-rings makes it eas-
ier to align both gears. Once gears are aligned,
remove starter to install O-rings being careful not
to rotate starter gear out of position, then reinstall
the starter.
Apply
LOCTITE 243 (BLUE) (P/N 293 800 060)
on re-
taining screws and torque to 10 N•m (89 lbf•
in
).
Connect the RED positive cable to the starter and
torque retaining nut to 7 N•m (62 lbf•
in
).
smr2009-034
323
Содержание GTX Limited iS 255 2009
