Section 04 FUEL SYSTEM
Subsection 03 (FUEL TANK AND FUEL PUMP)
smr2009-031-017_b
1. Quick connect fitting (high pressure fuel hose)
2. Vent hose
3. Harness connector
Disconnect filler hose from fuel tank.
NOTE:
Removing retaining screws of the filler
neck may help to disconnect hose from fuel tank.
smr2009-031-026_a
1. Filler hose
2. Retaining clamp
NOTE:
Take note of wiring harness, hoses and
cable routing for proper reinstallation. Also note
method used for securing with locking ties.
Detach fuel tank retaining straps.
Remove fuel tank from the vehicle.
Remove fuel pump as necessary. Refer to
FUEL
PUMP
in this subsection.
Inspect hull and flotation foams for wear.
Fuel Tank Installation
NOTE:
Apply torque values as specified in the ex-
ploded view.
Reinstall fuel pump if it was removed. Refer to
FUEL PUMP
in this subsection.
Ensure flotation foams are properly positioned.
Insert fuel tank in hull.
Place fuel tank retaining strap ends in anchoring
clips. Temporarily use tape to hold straps on the
top of fuel tank.
smr2009-031-027_a
1. Fuel tank retaining strap
2. Clip anchor securing strap to hull
Secure a long retaining strap end with a short
strap end on top of fuel tank.
NOTE:
Fuel tank retaining straps are paired one
long and one short together, and two consecutive
pairs are installed in opposing directions to stag-
ger the metal retainers. See following illustration.
smr2008-022-016_a
REAR FUEL TANK RETAINING STRAPS ILLUSTRATED
1. Long retaining straps
2. Short retaining straps
Properly secure wire harness, cables and hose as
prior to removal using appropriate locking ties.
Install fuel tank filler hose as shown. Torque re-
taining clamps as per exploded view.
270
smr2009-031
Содержание GTX Limited iS 255 2009
