Mitsubishi Heavy Industries ESA30E-25, Техническое руководство

Страница: 15 / 239

- -
'15 • HM-T-246
1.4.3 Handling precaution of CO
2
refrigerant
Regarding the safety considerations to high pressure, be careful not to give any damage on the refrigerant circuit piping of
heat pump water heater during servicing, and to purge a small amount of the refrigerant gradually by adjusting valve opening
properly to a place where there is no person. (See . () Method to purge CO refrigerant)
CO refrigerant itself is harmless, but if sucking the high concentration CO refrigerant, it may exert various influences on the
human body.
The influence on the human body exerted by the concentration of CO gas in the atmosphere is shown in the table ..
Concentration of CO gas
(vol%)
0.0
0.
Long-term safety limit (Critical concentration by weighted time average calculated
with hours of averaged permissible time)
.
phosphorus.
.0
Workability comes down and alternation of physiological function will emerge as the
alternation on weight, blood pressure and heart rate.
.0
Breathing becomes deeper and breathing rate is increased. It will be the state of
slightly gasping that is considerably discomfort feeling.
.0
results symptoms of poisoning.
to
It is the allowable limit. It will be the state of severely gasping and leads to
unconsciousness within about minutes.
to 0 It produces more serious symptoms, but it is not fatal within hour.
to 0
and paralysis. It leads to death within a few hours.
Table 1.3 The influence on the human body exerted by the concentration of CO
2
gas in the atmosphere
As shown in the table ., when the concentration of CO becomes % or more, it leads to the alternation of physi-
ological function and at to % it leads to unconsciousness within about minutes and at to 0% it leads coma
and then to death. Therefore be careful for handling it.
Since CO refrigerant is heavier than air and is likely to remain at the lower place, when CO refrigerant may leak or is
released, be careful to work with taking a measure to prevent from remaining CO on the floor by ventilating or such
ways.
The emergent measures at following states are mentioned below.
a) When sucking high concentration CO gas.
Move the victim immediately to the place filled with fresh air and warm up him and keep him at rest.
If he is unconscious, loosen his clothing, clear his air way and give artificial respiration and then make him
received treatment by medical doctor promptly.
b) When liquid CO stays on the skin
In case of mild frostbite, it is OK to rub down the affected area. However in case of severe frostbite, warm up the
affected area with lukewarm water and wrap it with gauze softly and then make him received treatment by medi-
cal doctor promptly.
c) When liquid CO gets into one’s eye
Flush the eye with freshwater immediately and then make him receive treatment by medical doctor promptly.
AMP Air Conditioning www.ampair.co.uk | sales@ampair.co.uk