mower equipped with ROPS in the raised and secured
position. Both retaining pins and hair pins must be
installed. Failure to use seat belt with ROPS will result in
serious injury in the event of a rollover.
9
ELECTRICAL SYSTEM
9.1
ELECTRICAL SYSTEM SAFETY
•
Remove key, disconnect battery cables by pulling inward
on RED battery quick disconnect handle in battery box
compartment and read owner’s manual before adjusting
or repairing unit.
•
Always remove key and disconnect battery cables by
pulling inward on RED battery quick disconnect handle
in battery box compartment before working on this unit.
•
Always disconnect battery cables by pulling inward on
RED battery quick disconnect handle in battery box
compartment when transporting unit.
•
Keep unit free of grass clippings, leaves and other debris.
DO NOT spray water to clean unit. Use only compressed
air. Wear adequate eye and hearing protection when
cleaning the unit.
•
Always wear safety glasses and protective gear near
battery. Use insulated tools.
•
Clean battery compartment, drive motor compartment,
mower deck, seat, etc., of all dirt and debris. Do not use
solvents, hard cleaners or abrasives.
•
With key in “ON” position, mower blade can engage
when deck blade ON/OFF switch is engaged, even if
drive motor is not turning. Keep area clear of bystanders
when engaging deck blade ON/OFF switch.
•
All maintenance and storage areas should be properly
ventilated in accordance with applicable fire codes and
ordinances to avoid fire hazards. Proper ventilation is
required to remove hydrogen gas from the area during
battery charging.
•
Never allow flames, sparks or smoking near batteries.
•
Keep batteries out of reach of children.
•
Always keep protective shields, covers and guards in
place and securely fastened. If they become damaged,
repair or replace immediately. Never modify or remove
safety devices.
9.2
ELECTRICAL SYSTEM
INFORMATION
The Greenworks Commercial mower is powered by a 82-volt
electrical system. It consists of the following components:
1. Deck controller (3) (Depending on model)
2. Deck Motor (3) (Depending on model)
3. Drive controller (2)
4. Accelerator - right (1)
5. Accelerator - left (1)
6. Digital battery display (1)
7. Integrated electric trans-axle (2)
8. Lithium Energy Modules (LEMs) (1)
9.3
BATTERY AND CHARGER
WARNING
Maintenance for the various electrical components found on
the Greenworks Commercial Mower should only be
performed by a Greenworks Commercial Mower trained
technician.
WARNING
When battery voltage becomes low, the mower blades will
stop, although the drive motors will continue to run,
enabling driver to continue to drive unit. When the batteries
discharge to this point, they require recharging. The unit
should immediately be returned to the battery charging area
and the unit connected to the battery charger.
WARNING
Do not attempt to cross roads or railways with low battery
levels.
9.3.1
BATTERY CHARGING PORT
The battery charging port is located on the right (with
operator seated) housing of the machine. Open the port cover
(30) to charge.
•
For CZ-series,
both quick charging port (32) and
standard charging port (31) are available.
•
For PZ series,
only standard charging port (31) is
available.
32
31
30
9.3.2
CHARGING RECOMMENDATIONS
WARNING
Do not smoke while servicing the batteries.
WARNING
Always wear safety glasses and protective clothing near
battery. Use insulated tools.
14
English
EN
P0802464-00 v1.2