Раздел 7. Техническое обслуживание
Беларус 80.1/80.2/82.1/82.2/82Р — Руководство по эксплуатации
84
7.3. TRACTOR MAINTENANCE SER-
VICING UNDER SPECIAL CONDI-
TIONS
When operating the tractor under special
conditions (at low temperatures, in de-
sert, running on sandy and marshy soils,
rocky grounds), the same adopted
maintenance intervals and scopes are
observed.
Besides, the works listed below are ei-
ther introduced in addition or carried out
more frequently.
When in operation in a desert, on
sandy soils, at elevated temperatures
and/or heavily dust-laden atmosphere.
Fill in the diesel-engine with oil and fuel
by a «closed» method. Every three shifts
change oil in the air cleaner pan.
When carrying out MS Schedule-1, be
sure to check:
•
oil in the diesel-engine; no mechanical
and/or other impurities in oil can be ad-
mitted. Change oil, as necessary;
•
the central air cleaner tube (the tube
should be clean). Wash and service the
air cleaner every 20 hours;
•
flush with a jet of water or blow through
with compressed air the coolant radiator
core. The radiator should be clean, with
no traces of oil on its surface. In the pro-
cess of MS Schedule-2 wash the fuel
tank cap.
When running the tractor at low tem-
peratures, be sure to warm up the
diesel-engine to
20-30 °
С before start-
ing the engine. At the end of a shift, refill
the tanks with fuel in full (at minus 30°
С
use arctic fuel), and drain condensate
from the pneumatic system bottles. The
cooling system should be filled with anti-
freezing solution.
When running the tractor on a rocky
ground, as well as under high-altitude
conditions.
Check the running gear and other tractor
components for damage by external in-
spection and every shift. Also, check tight-
ness of plugs on the diesel-engine crank-
case, rear axle and FDA, driving wheel at-
tachment. Check the radiator plugs in the
diesel-engine cooling system for leak-
tightness.
Operation under high-altitude condi-
tions,
to ensure against deterioration of
normal operation processes in the diesel-
engine, carry out adjustment of the duel
pump with the intent of reducing its out-
put within the limits as follows:
•
At 1500-2000 m above the sea level
–
reduce the pump delivery by 10%;
•
at 2000-2500 m
— by 15%;
•
at 2500-3000 m
— by 20 %;
•
operation at heights exceeding 3000
m should be discourage.
7.4. Technical servicing of the tractor
during preparation for storage, in
storage and after storage
Technical servicing of the tractor in the
listed cases should be carried out in ac-
cordance with the rules and norms speci-
fied under Section 9. «Storage Regula-
tions for the Tractor»).
