TEST
ACTION
APPLICABILITY
1
With the DRBIII
t
, record and erase DTC’s.
Turn the ignition off, wait 10 seconds, then turn the ignition on.
Operate the power sliding door several times if possible.
With the DRBIII
t
, read ACTIVE DTCs.
Does the DRBIII
t
display INCOMPLETE POWER OPEN - LATCH FAILURE?
All
Yes
→
Go To
2
No
→
Using the wiring diagram/schematic as a guide, inspect the
wiring and connectors for an intermittent condition. Operate the
door several times and check for any binding or other obstruc-
tions.
Perform BODY VERIFICATION TEST - VER 1.
2
Examine the door for proper fit and alignment, lose/ hard or torn seals, worn teeth on
the rack and gear (lower drive unit) or anything that would cause an obstruction to
proper operation.
Manually operate the other sliding door or of a known good vehicle and notice the
effort needed to open and close.
Compare the effort needed on the disabled door.
Does it take more effort to operate the door than it should?
All
Yes
→
Refer to Service information for the related symptom(s).
Perform BODY VERIFICATION TEST - VER 1.
No
→
Go To
3
3
With the DRBIII
t
in Inputs/Outputs, read the PAWL, RATCHET and FULL OPEN
switch state.
While observing the FULL OPEN switch state, manually move the door from full
open to part open. The switch should toggle from CLOSED to OPEN.
Move the door to the full open position. While observing the PAWL switch state, click
the latch with a screwdriver to the first detent. The PAWL should toggle from
CLOSED to OPEN.
Move the door to the full open position. While observing the RATCHET switch state,
click the latch with a screwdriver to the second detent. The RATCHET should toggle
from CLOSED to OPEN.
Repeat the above steps several times.
Select which switch failed:
All
FULL OPEN Switch
Go To
4
PAWL Switch
Go To
9
RATCHET Switch
Go To
13
All switches operated properly.
Go To
17
885
POWER DOORS - SLIDING
INCOMPLETE POWER CLOSE - LATCH FAILURE —
Continued
Summary of Contents for Caravan 2003
