Symptom:
FRONT MODE DOOR TRAVEL TOO SMALL (ACTIVE)
When Monitored and Set Condition:
FRONT MODE DOOR TRAVEL TOO SMALL (ACTIVE)
When Monitored:
With the ignition on and the IOD fuse installed.
Set Condition:
This DTC is set when the ATC monitors the travel range during system
initialization and the measured range is less than expected.
POSSIBLE CAUSES
CHECK THE ATC FOR DTCS
ATC
OBSTRUCTED MODE DOOR
MODE DOOR ACTUATOR
TEST
ACTION
APPLICABILITY
1
Turn the ignition on.
With the DRB, read the active ATC DTCs.
Is the FRONT MODE DOOR NOT RESPONDING DTC set?
All
Yes
→
Return to the symptom list and choose the symptom.
With the DRBIII
t
, reset the ATC after repair is complete.
Perform BODY VERIFICATION TEST - VER 1.
No
→
Go To
2
2
Turn the ignition off.
Disconnect the Mode Door Actuator harness connector.
Connect a 12-volt Test Light between the Mode Door Actuator harness connector
cavities.
Turn the ignition on.
While monitoring the test light, turn the mode control knob to each position.
Note: Observe test light for approximately 30 seconds.
Does the test light start to flash and stay flashing?
All
Yes
→
Go To
3
No
→
Replace the ATC.
With the DRBIII
t
, reset the ATC after repair is complete.
Perform BODY VERIFICATION TEST - VER 1.
3
Remove the Mode Door Actuator. Rotate the mode doors (doors only). Note: These
should rotate approximately 45 degrees from stop to stop.
Do the mode doors move smoothly in both directions?
All
Yes
→
Replace the Mode Door Actuator.
With the DRBIII
t
, reset the ATC after repair is complete.
Perform BODY VERIFICATION TEST - VER 1.
No
→
Repair or replace the mode door as necessary.
With the DRBIII
t
, reset the ATC after repair is complete.
Perform BODY VERIFICATION TEST - VER 1.
231
AUTOMATIC TEMPERATURE CONTROL
Summary of Contents for Caravan 2003
