Symptom:
INCOMPLETE LATCH RELEASE- NO REVERSE TO UNLOAD
CLUTCH
When Monitored and Set Condition:
INCOMPLETE LATCH RELEASE- NO REVERSE TO UNLOAD CLUTCH
When Monitored:
Whenever the power sliding door is operating.
Set Condition:
If the cinch release motor takes longer than 700 ms to perform a release
operation this code will set. The main causes of this code setting is some type of sticking
situation preventing the sector gear in the cinch release motor assembly to return to its
neutral position.
POSSIBLE CAUSES
DTC PRESENT
BINDING LATCH
CINCH RELEASE MOTOR ASSEMBLY
TEST
ACTION
APPLICABILITY
1
With the DRBIII
t
, record and erase DTC’s.
Turn the ignition off, wait 10 seconds, then turn the ignition on.
Operate the power sliding door several times if possible.
With the DRBIII
t
, read ACTIVE DTCs.
Does the DRBIII
t
display INCOMPLETE LATCH RELEASE - NO REVERSE TO
UNLOAD CLUTCH?
All
Yes
→
Go To
2
No
→
Operate the door several times and check for any binding or other
obstructions. To test the reverse action, open the sliding door part
way and continue holding the handle for 4 seconds. The motor
should run for approximately 100ms.
Perform BODY VERIFICATION TEST - VER 1.
2
Examine the sliding door for proper fit and alignment, loose/hard or torn seals or
anything that would cause an obstruction to proper operation.
Manually operate the sliding door of a known good vehicle and notice the effort
needed to open and close.
Compare the effort needed on the disabled sliding door.
Especially notice the effort needed to unlatch and latch the door.
Does it take more effort to operate the door than it should?
All
Yes
→
Refer to Service information for the related symptom(s).
Perform BODY VERIFICATION TEST - VER 1.
No
→
Replace the Cinch Release Motor Assembly..
Perform BODY VERIFICATION TEST - VER 1.
873
POWER DOORS - SLIDING
Summary of Contents for Caravan 2003
