Symptom:
INCOMPLETE LATCH RELEASE - RATCHET SWITCH FAILURE
When Monitored and Set Condition:
INCOMPLETE LATCH RELEASE - RATCHET SWITCH FAILURE
When Monitored:
Whenever the power sliding door is operating in an opening direction.
Set Condition:
The pawl switch was grounded but the ratchet switch remained open. This
code will set only in the release operation.
POSSIBLE CAUSES
DTC PRESENT
BINDING DOOR
POWER SLIDING DOOR MODULE - RATCHET CIRCUIT
GROUND WIRE OPEN
SLIDING DOOR AJAR SWITCH SENSE WIRE OPEN
RATCHET SWITCH
TEST
ACTION
APPLICABILITY
1
NOTE: This DTC will only set during the cinching operation after the 4
second time out. This may make it difficult to reproduce
With the DRBIII
t
, record and erase DTC’s.
Turn the ignition off, wait 10 seconds, then turn the ignition on.
Operate the power sliding door several times if possible.
With the DRBIII
t
, read ACTIVE DTCs.
Does the DRBIII
t
display INCOMPLETE LATCH RELEASE - RATCHET SWITCH
FAILURE?
All
Yes
→
Go To
2
No
→
Using the wiring diagram/schematic as a guide, inspect the
wiring and connectors for an intermittent condition. Operate the
door several times and check for any binding or other obstruc-
tions.
Perform BODY VERIFICATION TEST - VER 1.
2
Examine the door for proper fit and alignment, loose/ hard or torn seals, worn teeth
on the rack and gear (lower drive unit) or anything that would cause an obstruction
to proper operation.
Manually operate the other sliding door or of a known good vehicle and notice the
effort needed to open and close.
Compare the effort needed on the disabled door.
Especially notice the effort needed to unlatch and close the door.
Does it take more effort to operate the door than it should?
All
Yes
→
Refer to Service information for the related symptom(s).
Perform BODY VERIFICATION TEST - VER 1.
No
→
Go To
3
871
POWER DOORS - SLIDING
Summary of Contents for Caravan 2003
