Symptom:
INCOMPLETE LATCH CINCH - NO PAWL TRANSITION
When Monitored and Set Condition:
INCOMPLETE LATCH CINCH - NO PAWL TRANSITION
When Monitored:
Whenever the power liftgate in performing a cinching operation.
Set Condition:
The pawl switch was not detected as returning to ground during the
transition between secondary and primary cinch operation. NOTE: The liftgate may not be
fully cinched during this condition. The liftgate may cinch to primary but not be fully
seated and may pop off back to secondary.
POSSIBLE CAUSES
DTC PRESENT
BINDING LIFTGATE
GROUND WIRE OPEN
LIFTGATE PAWL SWITCH SENSE WIRE OPEN
LIFTGATE PAWL SWITCH SENSE WIRE SHORT TO GROUND
PAWL SWITCH
TEST
ACTION
APPLICABILITY
1
NOTE: This DTC will only set after the cinching operation. This may make
it difficult to reproduce.
With the DRBIII
t
, record and erase DTC’s.
Turn the ignition off, wait 10 seconds, then turn the ignition on.
Operate the power liftgate several times if possible.
With the DRBIII
t
, read ACTIVE DTCs.
Does the DRBIII
t
display INCOMPLETE LATCH CINCH - NO PAWL TRANSI-
TION?
All
Yes
→
Go To
2
No
→
Using the wiring diagram/schematic as a guide, inspect the
wiring and connectors for an intermittent condition. Operate the
door several times and check for any binding or other obstruc-
tions.
Perform BODY VERIFICATION TEST - VER 1.
2
Examine the liftgate for proper fit and alignment, lose/hard or torn seals, misaligned
latch striker or anything that would cause an obstruction to proper operation.
Manually operate the liftgate of a known good vehicle and notice the effort needed to
open and close.
Compare the effort needed on the disabled liftgate.
Does it take more effort to operate the liftgate than it should?
All
Yes
→
Refer to Service information for the related symptom(s).
Perform BODY VERIFICATION TEST - VER 1.
No
→
Go To
3
803
POWER DOORS - LIFTGATE
Summary of Contents for Caravan 2003
