Symptom:
*CABIN HEATER INOPERABLE FROM A/C - HEATER MODULE
(MTC)
POSSIBLE CAUSES
DCHA ACTIVATION CRITERIA NOT MET
NO PCI BUS COMMUNICATION WITH FCM/HVAC MODULE
FCM OR HAVC DTCS PRESENT
FCM FAULT
A/C - HEATER CONTROL MODULE FAULT
TEST
ACTION
APPLICABILITY
1
WARNING: DO NOT OPERATE THE DCHA IN AN ENCLOSED AREA SUCH
AS A GARAGE THAT DOES NOT HAVE EXHAUST VENTILATION FACILI-
TIES. ALWAYS VENT THE DCHA’s EXHAUST WHEN OPERATING THE
DCHA. FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN
PERSONAL INJURY OR DEATH.
CAUTION: DO NOT PERFORM THIS TEST UNLESS DIRECTED HERE BY
THE CABIN HEATER PRE-TEST. ALWAYS PERFORM THE CABIN HEATER
PRE-TEST PRIOR TO PERFORMING ANY OTHER CABIN HEATER TEST
FOR THE RESULT TO BE VALID.
Verify that all of the following criteria was met during the attempt to activate the
DCHA from the A/C - Heater Control Module.
The engine was running.
The engine’s coolant temperature was below 66°C (151°F).
The vehicle’s fuel tank had more than 1/8 of a tank of fuel.
The A/C - Heater Control Module’s Power switch was on.
The Blend Control was set above 90% reheat.
Was all criteria met during the attempt to activate the DCHA from the A/C - Heater
Control Module?
All
Yes
→
Go To
2
No
→
Attempt to activate the DCHA when all of the operating criteria
are met.
Perform CABIN HEATER VERIFICATION TEST - VER 1.
2
WARNING: DO NOT OPERATE THE DCHA IN AN ENCLOSED AREA SUCH
AS A GARAGE THAT DOES NOT HAVE EXHAUST VENTILATION FACILI-
TIES. ALWAYS VENT THE DCHA’s EXHAUST WHEN OPERATING THE
DCHA. FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN
PERSONAL INJURY OR DEATH.
Turn the ignition on.
With the DRBIII
t
, attempt to communicate with the FCM and the HVAC Module.
Was the DRBIII
t
able to communicate with the FCM and the HVAC Module?
All
Yes
→
Go To
3
No
→
Refer to Communication for the related symptom(s)
Perform CABIN HEATER VERIFICATION TEST - VER 1.
319
CABIN HEATER
Summary of Contents for Caravan 2003
