TEST
ACTION
APPLICABILITY
10
Turn the ignition off.
Disconnect the A/C - Heater Control C1 harness connector.
Disconnect all door actuator harness connectors whose circuit resistance was below
30.0 ohms.
For a door actuator in the front A/C - heater housing assembly, measure the
resistance between the Common Door Driver circuit and each applicable door driver
circuit.
For a door actuator in the rear A/C - heater housing assembly, measure the resistance
between the Rear Common Door Driver circuit and each applicable door driver
circuit.
Is the resistance below 10K ohms on any of the circuits?
All
Yes
→
Repair the door driver circuits with a resistance below 10K ohms
for a short to the Common Door Driver circuit or Rear Common
Door Driver circuit.
Perform BODY VERIFICATION TEST - VER 1.
No
→
Replace all door actuators with a resistance below 30.0 ohms in
accordance with the Service Information.
Perform BODY VERIFICATION TEST - VER 1.
11
Turn the ignition off.
Ensure that the A/C - Heater Control C1 harness connector is connected to the A/C
- Heater Control Module.
Turn the ignition on.
With the DRBIII
t
in HVAC, System Tests, actuate the Actuator Circuit Test.
What message does the DRBIII
t
display?
All
Same msg as from start of test
Replace the A/C - Heater Control Module in accordance with the
Service Information.
Perform BODY VERIFICATION TEST - VER 1.
Different msg than from start of test
Using the wiring diagram as a guide, inspect the wiring &
connectors for conditions causing an intermittent short that set
the original test msg. Repair as necessary. If DRB displays a msg
for a different door driver ckt, return to Test 1 of this Symptom.
Perform BODY VERIFICATION TEST - VER 1.
521
HEATING & A/C
ACT CKT TEST PASSED, OVERCURRENT DTCS ACTIVE - MTC —
Continued
Summary of Contents for Caravan 2003
